scholarly journals The Effect of Thickness and Reversal Frequency of Seaweed Gracilaria sp Drying

2021 ◽  
pp. 42-50
Author(s):  
Sitti Aisah ◽  
Mursalim Mursalim ◽  
Samsuar Samsuar
Keyword(s):  
Water Content ◽  
Drying Rate ◽  
Processing Industry ◽  
Reversal Frequency

Marketing of seaweed is still in the form of dried seaweed, but in fact the quality of the dried seaweedthat is sold by farmers has not met the standards required by the seaweed processing industry. One ofthe efforts that can be made to improve the quality of dried seaweed is by optimizing drying, namelyby adjusting the thickness and reversal frequency. Pile thickness of will determine the length of timedrying is carried out, while the frequency of reversal will determine the spread of heat that occurs inthe seaweed pile. The aim of this study was to determine the drying speed in seaweed Gracilaria spdrying and quality of dried sweaweed. The study was conducted with two treatments, namely pilethickness of 12, 16 and 20 cm and treatment of reversal frequency with an interval of 3 hours, 4 hoursand 5 hours. The parameters observed in this study were a decrease in water content, drying rate, andsensory test. The results showed that the drying of Gracilaria sp seaweed with a thicknessof 12 cm with a reversal frequency of each 3-4 hours is the best treatment in terms of color / brightnessand good texture with a drying rate of 0.462 kg H2O/kg solids hour.

scholarly journals Effects of different drying rates on the physiological quality of Coffea canephora Pierre seeds

2005 ◽  
Vol 17 (2) ◽  
pp. 199-205 ◽  
Author(s):  
Sttela Dellyzete Veiga Franco da Rosa ◽  
Delacyr da Silva Brandão Júnior ◽  
Édila Vilela de Resende Von Pinho ◽  
André Delly Veiga ◽  
Luiz Hildebrando de Castro e Silva
Keyword(s):  
Water Content ◽  
Storage Temperature ◽  
Removal Rate ◽  
Coffea Canephora ◽  
Development Stage ◽  
Seed Vigor ◽  
Drying Rate ◽  
Physiological Quality ◽  
Drying Rates

Desiccation tolerance in seeds depends on the species, development stage and drying conditions, especially the water removal rate. Coffea seeds are considered of intermediate performance, because they tolerate relative dehydration compared to orthodox seeds and are sensitive to low temperatures. The objective of this study was to verify the effect of different drying rates on the viability and storability of Coffea canephora seeds. A complete randomized experimental design was used, in a factorial 3 x 5 x 2 design, with three drying rates (fast, intermediate and slow), five final mean water contents after drying (51, 42, 33, 22 and 15 %) and two storage temperatures (10 and 20°C). The germination and seed vigor assessments, using radicle protrusion, cotyledon leaf opening, seedling emergence and emergence speed index, were performed shortly after drying and after two and four months storage. It was observed that with reduction in the water content there was reduction in the germination values and seed vigor, for all the drying rates. The greatest reductions in physiological quality occurred when the seeds were dried quickly and the best results were obtained at the intermediate drying rate. There was an effect of drying rate and storage temperature on the physiological quality of the seeds, and lower germination and vigor values were observed in seeds with lower water content stored at 20°C. C. canephora seeds were tolerant to desiccation down to 15 % water content and can be stored for four months at 10°C. A temperature of 20ºC can be used to store C. canephora seeds, as long as the water content is not reduced to values below 22 % water content.

scholarly journals Analysis of Type Cover on Drying Rate and Moisture Content

2020 ◽  
Vol 1 (4) ◽  
pp. 415-422
Author(s):  
Mietra Anggara ◽  
Irfan
Keyword(s):  
Water Content ◽  
Economic Value ◽  
Rectangular Prism ◽  
Drying Rate ◽  
Selling Price ◽  
Residual Water ◽  
Food Ingredients ◽  
Solar Dryer ◽  
Long Time

Seaweed is one of the marine commodities that has high economic value and benefits for humans, because seaweed can be processed into basic food ingredients and various types of products such as seaweed lunkhead, gelatin, cosmetic medicines and so on. The post-harvest handling process for the Papuan community, Kec. Taliwang, West Sumbawa Regency (NTB) is still done traditionally so natural drying usually takes a long time because the temperature and energy depend on sunlight. This will lead to a decline in the quality of seaweed products because temperature and energy depend on sunlight. One of the efforts to improve the quality of seaweed production is to reduce the water content, the maximum water content limit, which meets SNI 25% - 50%. In this study, four forms of cover were used, namely the cover form of a single oblique solar dryer, the cover form of the taper solar dryer, the cover form of the double slanted solar dryer, the cover form of the rectangular prism solar dryer. The peak drying rate lies on a double sloping cover of 0.40 g / minute, a taper cover of 0.37 g / minute, a rectangular prism cover of 0.34 g / minute and a single sloping cover of 0.30 g / minute. The hot peaks that are useful are located on a double sloping cover of 3.82 Watt, a taper cover of 2.80 Watt, a rectangular prism cover of 2.09 Watt and a single cover of 0.46 Watt. The peak of efficiency lies in the double sloping cover of 8.57%, taper cover of 6.28%, rectangular prism cover of 4.69% and single sloping cover of 2.28%. The peak of seaweed residual water content lies on a double sloping cover of 13.21%, a taper cover of 19.61%, a rectangular prism cover of 25.73 and a double sloping cover of 27.75%. This shows that drying using double sloping covers is more effective and efficient, so it can accelerate the drying rate and can increase the selling price of seaweed for seaweed farmers in Kertasari Village, Taliwang District, West Sumbawa (NTB).

scholarly journals Penurunan mutu dan pendugaan umur simpan sup krim instan labu kuning diperkaya tempe untuk lansia dengan metode accelerated shelf life testing (ASLT)

2020 ◽  
Vol 8 (2) ◽  
pp. 134-142
Author(s):  
Salma Shafrina Aulia ◽  
Budi Setiawan ◽  
Tiurma Sinaga ◽  
Ahmad Sulaeman
Keyword(s):  
Lipid Oxidation ◽  
Shelf Life ◽  
Water Content ◽  
Water Activity ◽  
Critical Parameter ◽  
Storage Period ◽  
Life Testing ◽  
Quality Of Water ◽  
Long Time

Background: Instant pumpkin cream soup enriched with tempeh had fulfilled 10% Recommended Dietary Allowances (RDA) for elderly so that it can be used as an easy-to-serve snack, but decreasing quality of instant cream soup will be happened if the instant cream soup was stored for a long time. Objectives: This study aimed to analyze quality of water content, water activity and lipid oxidation in instant pumpkin cream soup during storage and estimated the shelf life of pumpkin cream soup enriched with tempeh.Method:  Quality storage was analyzed using of water content, water activity (aw) and lipid oxidation. Estimation of shelf life was analyzed using Arrhenius Accelerated Shelf Life Testing (ASLT) model.Results: The results showed that the water content, aw levels and lipid oxidation of instant pumpkin cream soup increased during the storage period. The critical parameter used in this study was lipid oxidation. Instant cream soup without the addition of tempeh can last 447 days  while the cream soup with the addition of tempeh has a shelf life of 433 days.Conclusion: Quality of instant pumpkin cream soup decreased during the storage period and it would be expired over a year.

PERCEPATAN PENGOMPOSAN TANDAN KOSONG KELAPA SAWIT (TKKS) DENGAN PEMBERIAN UREA (Acceleration Composting Empty Fruit Bunches (Efb) With The Application Of Urea)

AgriPeat ◽  
2019 ◽  
Vol 18 (02) ◽  
pp. 113-124
Author(s):  
Journal Journal
Keyword(s):  
Weight Loss ◽  
Water Content ◽  
Palm Oil ◽  
Organic N ◽  
Empty Fruit Bunches ◽  
Randomized Design ◽  
Compost Application ◽  
Completely Randomized Design ◽  
Total P

                                                                                                                                   ABSTRAK Kelapa sawit merupakan tanaman perkebunan yang memegang peranan penting dalam industri pangan. Luas perkebunan kelapa sawit di Indonesia pada tahun 2014 mencapai 10 juta Ha. Pertumbuhan yang pesat diikuti dengan produksi crude palm oil (CPO) dan palm karnel oil (PKO) yang juga meningkat, sekaligus produk sampingan berupa limbah. Salah satu limbah pabrik kelapa sawit yang jumlahnya besar adalah tandan kosong kelapa sawit (TKKS). Tandan kosong kelapa sawit merupakan limbah organik yang berpotensi dimanfaatkan dibidang pertanian. Akan tetapi, TKKS memiliki nilai C/N yang cukup tinggi, akibatnya sukar dan lama untuk terdekomposisi. Salah satu cara pemanfaatan TKKS adalah dengan dilakukan pengomposan dengan pengkayaan urea. Diharapkan dengan perlakuan tersebut TKKS akan cepat terdekomposisi dan dapat segera dimanfaatkan oleh tanaman. Penelitian ini bertujuan untuk (1) mengetahui pengaruh pemberian urea terhadap pengomposan TKKS dan (2) mengetahui pengaruh peningkatan dosis urea terhadap kualitas kompos TKKS. Rancangan yang digunakan dalam penelitian ini adalah Rancangan Acak Lengkap (RAL) faktor tunggal dengan 5 perlakuan, yaitu U1 (urea 0 g setara dengan nilai C/N=), U2 (urea 30,9 g setara dengan nilai C/N=), U3 (urea 79,3 g setara dengan nilai C/N=), U4 (urea 176,1 g setara dengan nilai C/N=) dan U5 (urea 466,3 g setara dengan C/N = ) dan 9 ulangan, sehingga diperoleh 45 satuan percobaan. Hasil penelitian menunjukan bahwa pemberian urea berpengaruh sangat nyata terhadap susut bobot, kadar air, nilai pH kompos, C-organik, N-total, P-tersedia, dan nilai C/N, selain itu pemberian urea mengakibatkan terjadi perubahan tekstur dan warna pada kompos TKKS. Pemberian dosis urea 466,3 g mampu meningkatkan kandungan N-total, serta menurunkan nilai C/N dan nilai pH kompos. Pemberian dosis urea 79,3 g atau setara dengan C/N = mampu meningkatkan kandungan P-tersedia dan kadar air, menurunkan susut bobot dan kandungan C-organik, serta menunjukan perubahan tekstur dan warna yang lebih baik. Kata kunci: tanda kosongkelapa sawit (TKSS), kompos, urea                                                                                                                                        ABSTRACT Empty fruit bunches (EFB) is a solid wastes produced in large quantity from palm oil industry. Empty fruit bunches can be used as compost material, additionally difficult to decompose because it contain cellulose, hemicellulose, and lignin, as well as value of ratio C/N is high. Use EFB as compost material through the provision of urea has been done in this research. Urea are expected to reduce the value of ratio C/N and became a starter for microbial decomposers. The purpose of this research were (1) to determine the effect of urea on composting of EFB and (2) to determine the effect of increasing doses of urea to the quality of compost of EFB. This research was used a single factor of Completely Randomized Design (CRD) with 5 treatments, namely U1 (urea 0 g), U2 (urea 30,9 g), U3 (urea 79,3 g), U4 (urea 176,1 g), and U5 (urea 466,3 g), and 9 replications, until result 45 experimental units. The result showed that urea significant effect on weight loss, water content, value of pH compost, C-organic, N-total, P-available, and value of ratio C/N, besides urea resulted Widodoe, K. dkk Percepatan Pengomposan Tandan Kosong Kelapa Sawit…..…. 114 in a change in texture and color on the compost EFB. Application of urea 466,3 g was able to increase the content of N-total, reduce the value of ratio C/N and the value of pH compost. Application of urea 79,3 g can improve the content of P-available and water content, reduce the weight loss and the content of C-organic, and showed the changes in texture and color as better. Keywords: empty fruit bunches, compost, urea

The effect of export tax rebates on product quality: evidence from China's agricultural product processing industry

2021 ◽  
Vol ahead-of-print (ahead-of-print) ◽  
Author(s):  
Yue Liang ◽  
Jingqi Dang ◽  
Shuai Chen
Keyword(s):  
Quality Improvement ◽  
Product Quality ◽  
Policy Implications ◽  
Medium Size ◽  
Agricultural Product ◽  
Firm Innovation ◽  
Processing Industry ◽  
Content Type ◽  
Export Tax

PurposeThis study aims to establish the linkage among export tax rebate (ETR), firm innovation and product quality of Chinese agricultural product processing industry (APPI), so that more targeted policy implications can be discussed.Design/methodology/approachUsing highly disaggregated firm-product-destination-level data through 2001 to 2013 of Chinese APPI, this study employs a two-way fixed effects specification to establish the linkage between ETR and product quality, while the mediational model is adopted to examine potential mechanisms.FindingsBaseline estimates show that a 1% increase in ETR rate leads to a significant increase in the product quality of APPI by 0.12% on the whole. However, there is a nonlinear, inverse-U shaped relationship between ETR and product quality, and the optimal inflection point occurs when ERT rate equals 0.15. Mechanism analyses show that firm innovation is an important impact channel, which explains 9.8% of quality improvement induced by raising ETR. Further heterogeneous analyses reveal both the total effects of ETR on product quality and the mediation effects of innovation are dominated by young SMEs (small and medium-size enterprises).Practical implicationsAuthorities can promote the innovation and then product quality improvement of young SMEs by moderately increasing ETR rate. To ensure ETR more effective in improving quality, it is necessary for the government to encourage innovation. Authorities can reduce the risk of innovation failure for low-tech firms by increasing R&D subsidies, while ensuring innovation returns for high-tech firms in combination with stronger intellectual property protection.Originality/valueFirst, this is one of the earlier studies to explore the relationship between ETR and product quality specifically for Chinese APPI. Second, we show firm innovation as an important mediator so that policies aim at raising ETR rates are eventually beneficial to product quality. Third, using the highly disaggregated data, we allow ETR rate to vary across different products, which is an improvement in the accuracy of previous literature. Finally, our research provides additional empirical evidence for revealing the micro-mechanism of ETR affecting firm behaviors.

scholarly journals Physiological quality of Gliricidia sepium (Jacq.) Steud. (Leguminosae - Papilionoideae) seeds subjected to different storage conditions

2012 ◽  
Vol 36 (2) ◽  
pp. 229-235 ◽  
Author(s):  
Renata Conduru Ribeiro Reis ◽  
Claudinéia Regina Pelacani ◽  
Cimille Gabrielle Cardoso Antunes ◽  
Bárbara França Dantas ◽  
Renato Delmondez de Castro
Keyword(s):  
Water Content ◽  
Seed Viability ◽  
Gliricidia Sepium ◽  
Storage Conditions ◽  
Physiological Processes ◽  
Plastic Bags ◽  
Starting Point ◽  
Cultivated Plant ◽  
Physiological Quality

Studies of seed physiological processes represent the starting point for the sustainable utilization of native or cultivated plant species from the caatinga biome for which germination studies are still scarce. In order to determine adequate methods for the conservation of Gliricidia sepium seeds, the physiological quality of propagules exposed to different conditions and times of storage were examined. Recently collected seeds of G. sepium were analyzed immediately, while the other sample was stored for three, six, nine, or twelve months in plastic or paper bags under refrigeration or at room temperature for further analysis. The germination rates of seeds from each storage regime were determined and these rates compared to their water content. It was observed that germination capacity was directly related to changes in seed humidity. Storing seeds in plastic bags yielded the best conservation, mainly when they were stored at low temperatures. However, even at temperatures near 25°C it was possible to prolong seed viability when their water content was controlled through the use of impermeable packing.

Effects of differential drying rates on viability retention of recalcitrant seeds of Ekebergia capensis

1998 ◽  
Vol 8 (4) ◽  
pp. 463-471 ◽  
Author(s):  
N. W. Pammenter ◽  
Valerie Greggains ◽  
J. I. Kioko ◽  
J. Wesley-Smith ◽  
Patricia Berjak ◽  
...  
Keyword(s):  
Water Content ◽  
Exponential Function ◽  
Time Course ◽  
Drying Rate ◽  
Recalcitrant Seeds ◽  
Tissue Water ◽  
Initial Water ◽  
Viability Loss ◽  
Drying Rates ◽  
Water Contents

AbstractThe drying rate of whole seeds of Ekebergia capensis (Meliaceae) was shown to influence the response to desiccation, with rapidly dried seeds surviving to lower water contents. Short-term rapid drying (to water contents higher than those leading to viability loss) actually increased the rate of germination. The form of the time course of decline of axis water content varied with drying rate; slow drying could be described by an exponential function, whereas with rapid drying initial water loss was faster than predicted by an exponential function. These observations suggest that slow drying brought about homogeneous dehydration and that the rapid drying was uneven across the tissue. This raised the possibility that the different responses to dehydration were a function of different distributions of water in the axis tissue under the two drying regimes. However, ultrastructural observations indicated that different deleterious processes may be occurring under the different drying treatments. It was tentatively concluded that a major cause of viability loss in slowly dried material was likely to be a consequence of aqueous-based processes leading to considerable membrane degradation. Uneven distribution of tissue water could not be rejected as a contributory cause of the survival of rapidly dried seeds to low bulk water contents. The differential response to dehydration at different drying rates implies that it is not possible to determine a ‘critical water content’ for viability loss by recalcitrant seeds.

scholarly journals VARIAN IKAN NIKE (Awaous melanocephalus) DAN IKAN CAKALANG (Katsuwonus pelamis) TERHADAP MUTU KERUPUK

2018 ◽  
Vol 5 (2) ◽  
pp. 44
Author(s):  
Desi Arisanti
Keyword(s):  
Water Content ◽  
Ash Content ◽  
Nutritional Content ◽  
Katsuwonus Pelamis ◽  
Hedonic Method ◽  
Average Water ◽  
The Mean ◽  
Processed Form ◽  
Current Utilization

the current utilization of nike fish and tuna is still limited to fresh condition. Crackers are a very popular food by all levels of society. Utilization of nike fish and tuna in processed form with longer shelf life has not been done. Nutritional content of both types of fish is a reason in the selection as a basic ingredient in making crackers. The purpose of this research is to know the formulation of nike fish and tuna to the quality of crackers. The observation parameters in this study are the level of favorite or hedonic method, water content, ash content, bloom and texture analizer. The results showed that the average water content of nike fish crackers and skipjack fish from treatment A1 3.3%, treatment A2 3.29%, A3 3.77%. Mean of ash content at treatment of A1 1,97%, treatment of A2 1,55%, treatment of A3 1,58%. The average of A1 is 283,54%, A2 242,75%, A3 182,23%. and the mean of analyzer analyzer test at A1 1185,6%, A2 708,9%, and A3 783,83%. Based on the results and the discussion that has been done on the quality of crackers, it can be concluded that the best formula and liked by the panelists is formula A1

Sign in / Sign up

Export Citation Format

Share Document