scholarly journals Effect of Thermal Pretreatment on the Yield of Biogas from Microcoleous Vaginatus

2021 ◽  
Vol 17 (4) ◽  
pp. 250-256
Author(s):  
M. Haruna ◽  
O.R. Momoh ◽  
S. Bilal
Keyword(s):  
Cell Wall ◽  
Anaerobic Digestion ◽  
Biogas Production ◽  
Renewable Energy Sources ◽  
Research Work ◽  
Proximate Analysis ◽  
Biogas Yield ◽  
Bacteria Growth ◽  
Positive Effect ◽  
Made In

Biomass is being looked upon as one of the promising renewable energy sources for the future, with growing interest in microalgae conversion into biogas through anaerobic digestion. Recently, the ability of microalgae to treat waste water has doubled its potentials material today. However, in spite of the progress made in that regards, there are still challenges of algae conversion to biofuel, due to the presence of complex cell wall in some algae. Cell wall inhibits bacteria growth during degradation. In this research work 10 grams of Microcoleous vaginatus was treated in an oven at varying temperatures of 70, 75 and 80 oC for an hour, out of which 4 g was measured into 250 ml serum bottle for digestion at mesophilic temperature of 37 oC. Based on the results of proximate analysis, 69%increase in carbohydrate was attained with 72.7 – 148% reduction in moisture content. The biogas yield of untreated sample was 4.36 mLg−1 VS, while, pretreated samples at 70, 75 and 80 ℃ produced 8.39, 9.07 and 9.38 mLg−1VS (volatile solid) of biogas. This  corresponds to 92, 108 and 115% higher than that of untreated samples. However, thermal treatment of M. vaginatus prior to digestion show positive effect on carbohydrate extraction and enhanced biogas and methane yield as well. Therefore, this makes the substrate a good feedstock for biogas production. Keywords: Biomass, pretreatment, thermal, anaerobic digestion, degradation, Microcoleous vaginatus.

scholarly journals Biological And Thermal Pretreatment Of Lignocellulosic Materials For Enhanced Biogas Production

2021 ◽  
Author(s):  
Samer Dahahda
Keyword(s):  
Anaerobic Digestion ◽  
Organic Material ◽  
Fossil Fuels ◽  
Biogas Production ◽  
Renewable Energy Sources ◽  
Current Status ◽  
Lignocellulosic Materials ◽  
Thermal Pretreatment ◽  
Biological Pretreatment ◽  
Biogas Yield

The rapid depletion of natural resources and the environmental concerns associated with the use of fossil fuels as the main source of global energy is leading to an increased interest in alternative and renewable energy sources. Lignocellulosic biomass is the most abundant source of organic materials that can be utilized as an energy source. Anaerobic digestion has been proven to be an effective technology for converting organic material into energy products such as biogas. However, the nature of lignocellulosic materials hinders the ability of microorganisms in an anaerobic digestion process to degrade and convert organic material to biogas. Therefore, a pretreatment step is necessary to improve the degradability of lignocellulosic materials and achieve higher biogas yield. Several pretreatment methods have been studied over the past few years including physical, thermal, chemical and biological pretreatment. This paper reviews biological and thermal pretreatment as two main promising methods used to improve biogas production from lignocelluloses. A greater focus is given on enzymatic pretreatment which is one of the promising yet under-researched biological pretreatment method. The paper addresses challenges in degrading lignocellulosic materials and the current status of research to improve biogas yield from lignocelluloses through biological and thermal pretreatment.

scholarly journals Biological And Thermal Pretreatment Of Lignocellulosic Materials For Enhanced Biogas Production

2021 ◽  
Author(s):  
Samer Dahahda
Keyword(s):  
Anaerobic Digestion ◽  
Organic Material ◽  
Fossil Fuels ◽  
Biogas Production ◽  
Renewable Energy Sources ◽  
Current Status ◽  
Lignocellulosic Materials ◽  
Thermal Pretreatment ◽  
Biological Pretreatment ◽  
Biogas Yield

The rapid depletion of natural resources and the environmental concerns associated with the use of fossil fuels as the main source of global energy is leading to an increased interest in alternative and renewable energy sources. Lignocellulosic biomass is the most abundant source of organic materials that can be utilized as an energy source. Anaerobic digestion has been proven to be an effective technology for converting organic material into energy products such as biogas. However, the nature of lignocellulosic materials hinders the ability of microorganisms in an anaerobic digestion process to degrade and convert organic material to biogas. Therefore, a pretreatment step is necessary to improve the degradability of lignocellulosic materials and achieve higher biogas yield. Several pretreatment methods have been studied over the past few years including physical, thermal, chemical and biological pretreatment. This paper reviews biological and thermal pretreatment as two main promising methods used to improve biogas production from lignocelluloses. A greater focus is given on enzymatic pretreatment which is one of the promising yet under-researched biological pretreatment method. The paper addresses challenges in degrading lignocellulosic materials and the current status of research to improve biogas yield from lignocelluloses through biological and thermal pretreatment.

scholarly journals Wheat Straw Optimization via its Efficient Pretreatment for Improved Biogas Production

2020 ◽  
Vol 6 (6) ◽  
pp. 1056-1063 ◽  
Author(s):  
Muhammad Jaffar Memon ◽  
Abdul Rehman Memon
Keyword(s):  
Anaerobic Digestion ◽  
Wheat Straw ◽  
Potassium Hydroxide ◽  
Biogas Production ◽  
Research Work ◽  
Structural Components ◽  
Biogas Yield ◽  
Pretreated Wheat Straw ◽  
Total Lignin

The complex indigenous configuration of non-bio-labile wheat straw necessitates its pretreatment to optimize the breakdown of its structural components for its ultimate conversion into biogas by means of anaerobic digestion. In this research work, wheat straw was pretreated with potassium hydroxide (KOH) to facilitate its improved biodegradability. The pretreatment of wheat straw was also obvious in terms of its crystallinity resulting in the improved amorphous regions compared to the control wheat straw. The results showed that pretreated wheat straw digestion transpired into comparatively higher removal of TS (86%), VS (89%) and total lignin, cellulose and hemicellulose (22%) than that obtained with control wheat straw. Maximum biogas production accrued was 1550 mLN per day with optimized dosing of KOH compared to 967 mLN per day obtained with control wheat straw, implying that the cumulative biogas production was improved by 45% using pretreated wheat straw than that using control wheat straw. These results suggested that pretreated wheat straw digestion led to a significant improvement in the biogas yield.

scholarly journals Biogas potential of organic waste onboard cruise ships — a yet untapped energy source

2021 ◽  
Author(s):  
Kai Schumüller ◽  
Dirk Weichgrebe ◽  
Stephan Köster
Keyword(s):  
Energy Source ◽  
Anaerobic Digestion ◽  
Sewage Sludge ◽  
Food Waste ◽  
Energy Demand ◽  
Organic Waste ◽  
Biogas Production ◽  
Biogas Yield ◽  
Cruise Ships ◽  
Detailed Presentation

AbstractTo tap the organic waste generated onboard cruise ships is a very promising approach to reduce their adverse impact on the maritime environment. Biogas produced by means of onboard anaerobic digestion offers a complementary energy source for ships’ operation. This report comprises a detailed presentation of the results gained from comprehensive investigations on the gas yield from onboard substrates such as food waste, sewage sludge and screening solids. Each person onboard generates a total average of about 9 kg of organic waste per day. The performed analyses of substrates and anaerobic digestion tests revealed an accumulated methane yield of around 159 L per person per day. The anaerobic co-digestion of sewage sludge and food waste (50:50 VS) emerged as particularly effective and led to an increased biogas yield by 24%, compared to the mono-fermentation. In the best case, onboard biogas production can provide an energetic output of 82 W/P, on average covering 3.3 to 4.1% of the total energy demand of a cruise ship.

Production of Bio Gas from Vegetable and Flowers Wastes Using Anaerobic Digestion

2015 ◽  
Vol 787 ◽  
pp. 803-808 ◽  
Author(s):  
A. Deepanraj ◽  
S. Vijayalakshmi ◽  
J. Ranjitha
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Research Work ◽  
Pressure Gauge ◽  
Pig Manure ◽  
Future Research ◽  
Digital Pressure ◽  
Vegetable Wastes ◽  
Main Component

The present research paper describes about the anaerobic digestion of vegetable (Banana, Cauliflower, potato, and sweet potato) and flower wastes (Rose, sambangi, gulmohar, marigold, golden shower tree, silk tree mimosa) in a 1L capacity of anaerobic digestor using pig manure as an inoculums. The digester was operated in the ratio of 1:1 of substrate to inoculums at RT. The substrate concentrations are varied such as 5%, 7%, and 10% was used and amount of gas produced was analysed using digital pressure gauge. The results obtained showed that, marigold flower had given higher yield of biogas than vegetable wastes and the digestion period was less. The average biogas production potential of withered flowers was observed as 14.36 g/kg in 5 days, where in case of vegetable wastes it was 10.0234 g/kg in 6 days. The study showed that flowers which are available in abundant in India is thrown away within a day, in the environment. These feedstocks are good feed stock for the production of biogas. The generation of biogas from flowers and vegetable waste upholds the concept of waste to wealth in enhancing sustainability of development. The future research work is mainly focused on the characterization of the main component present in the bio-gas using sophisticated instruments.

scholarly journals Biogas Production from Combined Irish Potato and Poultry Wastes: Optimization and Kinetic Studies

2018 ◽  
Vol 7 (3.36) ◽  
pp. 170
Author(s):  
Umar M. Ibrahim ◽  
Saeed I. Ahmed ◽  
Babagana Gutti ◽  
Idris M. Muhammad ◽  
Usman D. Hamza ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Kinetic Parameters ◽  
Ph Value ◽  
Biogas Production ◽  
Irish Potato ◽  
Coefficient Of Determination ◽  
Optimum Conditions ◽  
Biogas Yield ◽  
Potato Waste ◽  
Initial Ph

The combination of Irish potato waste (IPW) and poultry waste (PW) can form a synergy resulting into an effective substrate for a better biogas production due to some materials they contain. In this work, optimization and kinetic study of biogas production from anaerobic digestion of IPW and PW was investigated. Response surface methodology (RSM) was applied to optimize conditions such as initial pH, solids concentrations and waste ratios. The anaerobic digestion of the two wastes was carried out in the mesophilic condition and Box-Behnken design (BBD) was used to develop and analyze a predictive model which describes the biogas yield. The results revealed that there is a good fit between the experimental and the predicted biogas yield as revealed by the coefficient of determination (R2) value of 97.93%. Optimization using quadratic RSM predicts biogas yield of 19.75% at the optimal conditions of initial pH value 7.28, solids concentration (w/v) 9.85% and waste ratio (IPW:PW) 45:55%. The reaction was observed to have followed a first order kinetics having R2 and relative squared error (RSE) values of 90.61 and 9.63% respectively. Kinetic parameters, such as rate constant and half-life of the biogas yield were evaluated at optimum conditions to be 0.0392 day-1 and 17.68 days respectively. The optimum conditions and kinetic parameters generated from this research can be used to design real bio-digesters, monitor substrate concentrations, simulate biochemical processes and predict performance of bio-digesters using IPW and PW as substrate.  

Cultured and Uncultured Microbial Community Associated With Biogas Production

2021 ◽  
Author(s):  
Júlia Ronzella Ottoni ◽  
Suzan Prado Fernandes Bernal ◽  
Tiago Joelzer Marteres ◽  
Franciele Natividade Luiz ◽  
Viviane Piccin dos Santos ◽  
...  
Keyword(s):  
Renewable Energy ◽  
Microbial Community ◽  
Anaerobic Digestion ◽  
Biogas Production ◽  
Renewable Energy Sources ◽  
Starter Culture ◽  
Sequencing Analysis ◽  
Industrial Plants ◽  
Comprehensive Information ◽  
Culture Independent

Abstract The search for sustainable development has led countries around the world to seek the improvement of technologies that use renewable energy sources. One of the alternatives in the production of renewable energy comes from the use of waste including urban solids, animal excrement from livestock and biomass residues from agro-industrial plants. These materials may be used in the production of biogas, making its production highly sustainable and environmentally friendly, in addition to reducing public expenses for the treatment of those wastes. The present study evaluated the cultivated and uncultivated microbial community from a substrate (starter) used as an adapter for biogas production in anaerobic digestion processes. 16S rDNA metabarcoding revealed domain of bacteria belonging to the phyla Firmicutes, Bacteroidota, Chloroflexi and Synergistota. The methanogenic group was represented by the phyla Halobacterota and Euryarchaeota. Through 16S rRNA sequencing analysis of isolates recovered from the starter culture, the genera Rhodococcus, Vagococcus, Lysinibacillus, Niallia, Priestia, Robertmurraya, Luteimonas and Proteiniclasticum were recovered, groups that were not observed in the metabarcoding data. The groups mentioned are involved in the metabolism pathways of sugars and other compounds derived from lignocellulosic material, as well as in anaerobic methane production processes. The results demonstrate that culture-dependent approaches, such as isolation and sequencing of isolates, as well as culture-independent studies, such as the Metabarcoding approach, are complementary methodologies that, when integrated, provide robust and comprehensive information about the microbial communities involved in various processes, including the production of biogas in anaerobic digestion processes.

Influence of Ultrasound on the Synthesis of Biogas During Disposal of Beer Spent Grain

2021 ◽  
pp. 33-38
Author(s):  
Владимир Владимирович Житков ◽  
Борис Николаевич Федоренко
Keyword(s):  
Anaerobic Digestion ◽  
Energy Production ◽  
Biogas Production ◽  
Organic Substances ◽  
Ultrasonic Pretreatment ◽  
Biogas Yield ◽  
Spent Grains ◽  
Efficient Resource ◽  
Spent Grain ◽  
Environmentally Friendly Process

Ультразвуковая предварительная обработка считается экологически чистым процессом для повышения биоразлагаемости органических веществ при анаэробном сбраживании. Однако количество потребляемой энергии во время предварительной обработки является проблемой, особенно в тех случаях, когда производство энергии является основной целью биогазовой установки. Основной целью настоящего исследования работы было изучение эффективности ультразвуковой предварительной обработки для увеличения производства биогаза из отходов пивоваренного производства - пивной дробины. Результаты показали, что применение частоты 40 кГц при температуре 40 °С соответственно привело к увеличению выхода биогаза на 83%. Методология показала положительный результат в отношении содержания метана и скорости производства биогаза. Использование ультразвуковой предварительной обработки в отношении пивоваренной дробины для производства биогаза, по-видимому, позволяет решить проблемы не только эффективной утилизации пивоваренных отходов, но и создать экономически эффективный ресурс возобновляемой энергии на пивоваренном или аффилированном с ним производстве. Ultrasonic pretreatment is considered an environmentally friendly process to increase the biodegradability of organic substances during anaerobic digestion. However, the amount of energy consumed during pretreatment is a problem, especially in cases where energy production is the main purpose of the biogas plant. The main purpose of this study was to study the effectiveness of ultrasonic pretreatment to increase the production of biogas from brewing waste - brewer's grains. The results showed that the use of a frequency of 40 kHz at a temperature of 40 °C, respectively, led to an increase in the biogas yield by 83%. The methodology showed a positive result in terms of methane content and biogas production rate. The use of ultrasonic pretreatment for brewing spent grains for biogas production seems to solve the problems of not only efficient disposal of brewing waste, but also to create an economically efficient resource of renewable energy in brewing or its affiliated production.

scholarly journals Evaluation of Anaerobic Digestion of Dairy Wastewater in an Innovative Multi-Section Horizontal Flow Reactor

Energies ◽  
2020 ◽  
Vol 13 (9) ◽  
pp. 2392 ◽  
Author(s):  
Marcin Dębowski ◽  
Marcin Zieliński ◽  
Marta Kisielewska ◽  
Joanna Kazimierowicz
Keyword(s):  
Wastewater Treatment ◽  
Anaerobic Digestion ◽  
Flow Reactor ◽  
Biogas Production ◽  
Oxygen Demand ◽  
Methane Content ◽  
Dairy Wastewater ◽  
Horizontal Flow ◽  
Organic Loading Rate ◽  
Biogas Yield

The aim of this study was the performance evaluation of anaerobic digestion of dairy wastewater in a multi-section horizontal flow reactor (HFAR) equipped with microwave and ultrasonic generators to stimulate biochemical processes. The effects of increasing organic loading rate (OLR) ranging from 1.0 g chemical oxygen demand (COD)/L·d to 4.0 g COD/L·d on treatment performance, biogas production, and percentage of methane yield were determined. The highest organic compounds removals (about 85% as COD and total organic carbon—TOC) were obtained at OLR of 1.0–2.0 g COD/L·d. The highest biogas yield of 0.33 ± 0.03 L/g COD removed and methane content in biogas of 68.1 ± 5.8% were recorded at OLR of 1.0 g COD/L·d, while at OLR of 2.0 g COD/L·d it was 0.31 ± 0.02 L/COD removed and 66.3 ± 5.7%, respectively. Increasing of the OLR led to a reduction in biogas productivity as well as a decrease in methane content in biogas. The best technological effects were recorded in series with an operating mode of ultrasonic generators of 2 min work/28 min break. More intensive sonication reduced the efficiency of anaerobic digestion of dairy wastewater as well as biogas production. A low nutrient removal efficiency was observed in all tested series of the experiment, which ranged from 2.04 ± 0.38 to 4.59 ± 0.68% for phosphorus and from 9.67 ± 3.36 to 20.36 ± 0.32% for nitrogen. The effects obtained in the study (referring to the efficiency of wastewater treatment, biogas production, as well as to the results of economic analysis) proved that the HFAR can be competitive to existing industrial technologies for food wastewater treatment.

scholarly journals Opportunity of Biogas Production from Solid Organic Wastes through Anaerobic Digestion

2018 ◽  
Vol 65 ◽  
pp. 05025 ◽  
Author(s):  
Sagor Kumar Pramanik ◽  
Fatihah Binti Suja ◽  
Biplob Kumar Pramanik ◽  
Shahrom Bindi Md Zain
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Nutrient Balance ◽  
Organic Wastes ◽  
Organic Loading Rate ◽  
Biogas Yield ◽  
Carbon And Nitrogen ◽  
Potential Risks ◽  
Nitrogen Ratio ◽  
Pre Treatment

Solid organic wastes create potential risks to environmental pollution and human health due to the uncontrolled discharge of huge quantities of hazardous wastes from numerous sources. Now-a-days, anaerobic digestion (AD) is considered as a verified and effective alternative compared to other techniques for treating solid organic waste. The paper reviewed the biological process and parameters involved in the AD along with the factors could enhance the AD process. Hydrolysis is considered as a rate-limiting phase in the complex AD process. The performance and stability of AD process is highly influenced by various operating parameters like temperature, pH, carbon and nitrogen ratio, retention time, and organic loading rate. Different pre-treatment (e.g. mechanical, chemical and biological) could enhance the AD process and the biogas yield. Co-digestion can also be used to provide suitable nutrient balance inside the digester. Challenges of the anaerobic digestion for biogas production are also discussed.

Sign in / Sign up

Export Citation Format

Share Document