scholarly journals Performance Evaluation of Cyclone Particulate Controller and Wet Scrubber Unit in Paper Mill 7/8 PT. Pura Nusapersada Kudus

2020 ◽  
Vol 17 (2) ◽  
pp. 144-153
Author(s):  
Fauziyah Rahmawati ◽  
Budi Prasetyo Samadikun ◽  
Mochtar Hadiwidodo
Keyword(s):  
Quality Standards ◽  
Paper Mill ◽  
Air Pollutant ◽  
Market Demand ◽  
Recycled Paper ◽  
Wet Scrubbers ◽  
Wet Scrubber ◽  
Control Devices ◽  
Environment Regulation

The need is increasing in line with the high market demand for a product. One product that is widely used is paper. One of the recycled paper industries is PT. Pura Nusapersada Unit Paper Mill 7/8, where the production process uses water vapor from a coal-fired boiler. This process can produce ash that can pollute the air so that air pollutant control devices such as cyclones and wet scrubbers are needed. It is necessary to evaluate the efficiency of the cyclone and wet scrubber by knowing the specifications and working principles of the tool, the emissions produced, the effectiveness of the equipment, the factors that influence, problems, operation, and maintenance. The method used is direct observation, interviews, data in the form of documents, references, and routine reports. The cyclone used is a multi-cyclone type, and the wet scrubber is a venturi scrubber type. From the calculations that have been done, the efficiency of the Hitachi Boiler is 94.195%, and the Hamada II Boiler is 96.844%. The boiler produces emissions that meet quality standards for the Minister of Environment Regulation No. 07/2007. The efficiency calculation should be done once a year so that the quality of the equipment is monitored and does not pollute the surrounding air quality.

A rapid tool for emission outlet concentration simulation of scrubber and make-up air unit at different inlet concentrations

2017 ◽  
Vol 38 (4) ◽  
pp. 461-474
Author(s):  
Chi-Wen Kuo ◽  
Tzu-Sou Chuang ◽  
Luh-Maan Chang
Keyword(s):  
Removal Efficiency ◽  
Historical Record ◽  
Inlet Concentration ◽  
Outlet Concentration ◽  
Proposed Model ◽  
Clean Manufacturing ◽  
Wet Scrubbers ◽  
Wet Scrubber

Currently in the cleanroom-related industries, both the air quality of indoors intake and outdoors emission should be controlled at a certain level. Wet scrubbers and air washers are the main facilities to clean up air for the process required. However, previous studies have found that these devices typically have lower removal efficiency for low inlet concentration contaminations; little information is available to explain the efficiency deterioration and only on the empirical basis. A theoretical model is proposed, which applies Fick’s second law to derive a rapid efficiency simulating formula. This model is different from the empirical equations of former studies, and is able to describe the relationship between the inlet concentration and removal efficiency of the air washing facilities. Moreover, the calculation time of the nonlinear recurrence equation is effectively lessened by the Euler equation and proven to be practical and concise for the rapid efficiency determination. Confirmation of the simulation formula was conducted by using the experimental data from the previous studies of the wet scrubber and in situ historical record of a make-up air unit. In this article, we describe how an outlet concentration and removal efficiency can be predicted using a generic simulating formula, leading to better design with less effort. The proposed model and equation minimize the design complexity and help to optimize the sizing and operational control of the air washing facilities. This not only decreases the construction and operating costs, but also lead to better energy usage. Practical application: Engineers can use the output of this paper to optimize air washer facility designs instead of intuitively extending the rinsing duration or enlarging the scale of the equipment. The model can be applied to both residential and industrial air washers to predict the efficiency and evaluate the performance. It also allows the quantitative analysis and risk assessment of an abrupt air washer breakdown in the clean manufacturing industries.

scholarly journals PENURUNAN KADAR BESI DAN KROMIUM LIMBAH CAIR LABORATORIUM TEKNIK LINGKUNGAN DENGAN PENGENCERAN, KOAGULASI DAN ADSOBSI

2020 ◽  
Vol 14 (1) ◽  
pp. 74
Author(s):  
Indah Nurhayati ◽  
Sela Vigiani ◽  
Dian Majid
Keyword(s):  
Waste Water ◽  
Treatment Process ◽  
Adsorption Process ◽  
Operating Time ◽  
Quality Standards ◽  
Quality Standard ◽  
Total Chromium ◽  
Wastewater Quality ◽  
Environment Regulation

The purposes of this study is to examine the effect of flowrate and operating time on decreasing Fe and Cr, assessing the quality of wastewater after being treated with dilution, neutralization, coagulation and adsorption especially for the parameters Cr, Fe and pH. The variables in this study are the flow of waste water that is 100 mL / min and 140 mL / min, operating time for 60 minutes. The adsorption process is carried out continuously with down flow. Adsorbents in the form of activated zeolite and activated carbon are arranged in stages in a PVC reactor. The results of this study are 100 ml/min discharge can reduce total Fe by 99.9% from 1,767 mg/L to 0,971 mg/L and total chromium 99.2% from 48.7 mg/L to 0,39 mg/L. 140 ml/minute discharge can reduce total Fe 99.9% from 1,767 mg/L to 0.99 mg/L and total chrome 99% from 48.7 mg/L to 0.45 mg/L. Waste water quality, especially for the parameters of Cr, Fe and pH, after the treatment process have met the quality standard in accordance with Minister of Environment Regulation No. 5 of 2014 concerning Wastewater Quality Standards.

Changes in Air Quality of the Yuxi City Urban Area

2014 ◽  
Vol 1021 ◽  
pp. 225-228
Author(s):  
Cheng Qiu ◽  
Hong Chen ◽  
Chun Li Ye ◽  
Yan Jun Yang ◽  
Chang Bing Ye
Keyword(s):  
Air Pollution ◽  
Air Quality ◽  
Urban Area ◽  
Health Problem ◽  
Quality Index ◽  
Quality Standards ◽  
Air Pollutant ◽  
Air Quality Index ◽  
Air Quality Standards

Air pollution causes health problem. The paper simply analyzed the changes of air quality in the Yuxi city urban area from 2006 to 2012. In the Yuxi city urban area between 2006 and 2012, SO2 levels increased about 43.9 percent; NO2 levels increased about 13.3 percent; PM10 levels in 2012 decreased about 1.5 percent. By evaluating the air quality in the Yuxi city urban area, the results showed that air quality index was the maximum in 2009, and the quality of the air in Yuxi became worse from 2006 to 2012, air pollution in 2009 was the heaviest between 2006 to 2012. After adopting P.R.C EPA air quality standards (GB3095-2012) in 2013, the first air pollutant in Yuxi is PM10, and then it is SO2 among SO2, NO2 and PM10.Much should beend done to reduce the amount of PM10 and SO2 released.

Studi fortifikasi hidrolisat protein udang rebon (mysis relicta) pada mie sagu

2020 ◽  
Vol 6 (1) ◽  
pp. 039
Author(s):  
Trie Omitha Purba ◽  
Suparmi Suparmi ◽  
Dahlia Dahlia
Keyword(s):  
Experimental Method ◽  
Proximate Composition ◽  
Protein Hydrolysate ◽  
Quality Standards ◽  
Processing Technology ◽  
Fish Processing ◽  
Mysis Relicta ◽  
Marine Chemistry ◽  
Randomized Design

The study aimed to determine the effect of rebon shirmp (mysis relicta) protein hydrolisate fortification to the sago noodles and to observe the characteristics of the sago noodles produced. The research was carried on in February – April 2019 in the  Laboratory of Fish Processing Technology, Integrated Laboratories, and the Fisheries and Marine Chemistry Laboratories at the Universitas Riau. The method used was the experimental method, designedas a non-factorial complete randomized design. The treatment conducted was addingof rebon shrimp protein hydrolysate at 4 level concentrations (0%, 5%, 10% dan 15%). The variables assessed were the quality of organoleptic (appearance, texture, odor, flavor) and the proximate composition. The results showed that the proteinhydrolysate of rebon shrimp at concentration of 15% was the best treatment and in accordance to the quality standards of dried noodles (SNI 01-2974-1996), indicated bythe highest organoleptic qualityof the dried noodles produced, including: the appearance that was brown, less attractive, whole, less neat; the texture that was dry and compact; the aroma that was quite fragrant, spesific rebon shrimp; and the taste that was quite tasty and shrimp flavored. The proximate composition ofthe best product was presented by the content of moisture, ash, fat, protein, and carbohydrate at 7.55%,1.02%, 0.17%, 16.76%, and 74.49%, respectively.Keywords: Hydrolysate protein, rebon shrimp, sago noodles

A New Life for the St. Croix River

1988 ◽  
Vol 23 (4) ◽  
pp. 568-577
Author(s):  
Harold S. Bailey
Keyword(s):  
Water Quality ◽  
Dissolved Oxygen ◽  
Discharge Rate ◽  
Paper Mill ◽  
Regulated River ◽  
Secondary Treatment ◽  
Pulp And Paper Mill ◽  
Oxygen Regime ◽  
Oxygen Concentrations

Abstract The water quality of the upper 110 kilometres of the St. Croix River is considered to be pristine. A major industrial discharge renders the lower 14 kilometres of the river a water quality limited segment. Prior to 1970 the Georgia-Pacific Pulp and Paper Mill at Woodland, Maine, discharged untreated effluent directly into the river causing dissolved oxygen concentrations to drop well below 5 mg/L, the objective chosen in the interest of restoring endemic fish populations. Since 1972, the Mill has installed primary and secondary treatment, regulated river discharge rate and effluent composition which has greatly improved the summer dissolved oxygen regime. By 1980, dissolved oxygen concentrations were generally above 5.0 mg/L and restocking the river with Atlantic Salmon (Salmo salar) was initiated.

Management and Status of Japanese Public Waters

1991 ◽  
Vol 23 (1-3) ◽  
pp. 1-10 ◽  
Author(s):  
Takeshi Goda
Keyword(s):  
Water Quality ◽  
Coastal Waters ◽  
Industrial Wastewater ◽  
Quality Standards ◽  
Water Bodies ◽  
Industrial Wastewaters ◽  
Quality Of Water ◽  
Japanese Rivers ◽  
Per Capita

The management and status of public water bodies in Japan is discussed. The environmental quality standards which have been set and the levels of compliance with these standards are shown. The water quality of Japanese rivers, lakes, reservoirs, wetlands and coastal waters is described, and eutrophication problems are mentioned. The effects of changes in population density and levels of recycling of industrial wastewaters on the quality of water bodies are discussed. Almost 75% of industrial wastewater is now recycled. Per capita availability of freshwater in Japan is comparatively low, and the construction of 530 dams, in addition to the 2393 dams already in operation, is planned. Irrigation effluents from paddy fields are a major factor which influences river water quality in Japan. The improvement of water quality using various methods is discussed.

What Advantages Can Be Expected from the Acceptance of Variable Quality Standards for Sewage Treatment Effluents?

1988 ◽  
Vol 20 (4-5) ◽  
pp. 249-251
Author(s):  
Jacques Bernard
Keyword(s):  
Water Quality ◽  
Sewage Treatment ◽  
Quality Standards ◽  
Quality Level ◽  
Environment Protection ◽  
Economical Benefit ◽  
Quality Objective ◽  
Set Up ◽  
Variable Quality

The flow and the water quality of the rivers vary throughout the year. Very frequently the environment protection authorities set up a quality objective for the river water and this mini mum quality level is constant. So, it wou1d seem possible to accept variable quality standards for plant effluents. A first approach of the problem,by a small French task group,based on three actual cases leads to the provisory conclusion that such a regulation is suitable and presents economical benefit only in some very limit ed cases.

scholarly journals The effects of energy paths and emission controls and standards on future trends in China's emissions of primary air pollutants

2014 ◽  
Vol 14 (17) ◽  
pp. 8849-8868 ◽  
Author(s):  
Y. Zhao ◽  
J. Zhang ◽  
C. P. Nielsen
Keyword(s):  
Air Pollutants ◽  
Control Strategies ◽  
Emission Control ◽  
Pollution Prevention ◽  
Air Pollutant ◽  
Pollutant Emissions ◽  
Carbonaceous Aerosols ◽  
Emission Controls ◽  
Control Devices ◽  
Anthropogenic Pollutant

Abstract. To examine the efficacy of China's actions to control atmospheric pollution, three levels of growth of energy consumption and three levels of implementation of emission controls are estimated, generating a total of nine combined activity-emission control scenarios that are then used to estimate trends of national emissions of primary air pollutants through 2030. The emission control strategies are expected to have more effects than the energy paths on the future emission trends for all the concerned pollutants. As recently promulgated national action plans of air pollution prevention and control (NAPAPPC) are implemented, China's anthropogenic pollutant emissions should decline. For example, the emissions of SO2, NOx, total suspended particles (TSP), PM10, and PM2.5 are estimated to decline 7, 20, 41, 34, and 31% from 2010 to 2030, respectively, in the "best guess" scenario that includes national commitment of energy saving policy and implementation of NAPAPPC. Should the issued/proposed emission standards be fully achieved, a less likely scenario, annual emissions would be further reduced, ranging from 17 (for primary PM2.5) to 29% (for NOx) declines in 2015, and the analogue numbers would be 12 and 24% in 2030. The uncertainties of emission projections result mainly from the uncertain operational conditions of swiftly proliferating air pollutant control devices and lack of detailed information about emission control plans by region. The predicted emission trends by sector and chemical species raise concerns about current pollution control strategies: the potential for emissions abatement in key sectors may be declining due to the near saturation of emission control devices use; risks of ecosystem acidification could rise because emissions of alkaline base cations may be declining faster than those of SO2; and radiative forcing could rise because emissions of positive-forcing carbonaceous aerosols may decline more slowly than those of SO2 emissions and thereby concentrations of negative-forcing sulfate particles. Expanded control of emissions of fine particles and carbonaceous aerosols from small industrial and residential sources is recommended, and a more comprehensive emission control strategy targeting a wider range of pollutants (volatile organic compounds, NH3 and CO, etc.) and taking account of more diverse environmental impacts is also urgently needed.

scholarly journals Conceptualizing and Fostering the Quality of CES Through a Dutch National Network on CES (NEON)

HEC Forum ◽  
2021 ◽  
Author(s):  
Laura Hartman ◽  
Guy Widdershoven ◽  
Eva van Baarle ◽  
Froukje Weidema ◽  
Bert Molewijk
Keyword(s):  
Quality Standards ◽  
Evaluation Methodology ◽  
Clinical Ethics Support ◽  
National Network ◽  
Responsive Evaluation ◽  
Evaluation Approach ◽  
Ethics Support ◽  
Similarities And Differences ◽  
The Relationship

AbstractThe prevalence of Clinical ethics support (CES) services is increasing. Yet, questions about what quality of CES entails and how to foster the quality of CES remain. This paper describes the development of a national network (NEON), which aimed to conceptualize and foster the quality of CES in the Netherlands simultaneously. Our methodology was inspired by a responsive evaluation approach which shares some of our key theoretical presuppositions of CES. A responsive evaluation methodology engages stakeholders in developing quality standards of a certain practice, instead of evaluating a practice by predefined standards. In this paper, we describe the relationship between our theoretical viewpoint on CES and a responsive evaluation methodology. Then we describe the development of the network (NEON) and focus on three activities that exemplify our approach. In the discussion, we reflect on the similarities and differences between our approach and other international initiatives focusing on the quality of CES.

New Standards for the Chemical Quality of Water in Europe under the New Directive 2013/39/EU

2014 ◽  
Vol 11 (1) ◽  
pp. 31-48 ◽  
Author(s):  
Katharina Kern
Keyword(s):  
Water Quality ◽  
Surface Water ◽  
Water Policy ◽  
Quality Standards ◽  
Priority Substances ◽  
Chemical Quality ◽  
Quality Of Water ◽  
Harmful Substances ◽  
Watch List

Directive 2013/39/EU amending Directives 2000/60/EC and 2008/105/EC as regards priority substances in the field of water policy was adopted on 12 August 2013. It revises crucial rules on determining the chemical quality of surface water in Europe (e.g. identification of new harmful substances, updating of environmental quality standards, introduction of a new “watch list” mechanism) and establishes new standards for the protection of water in Europe. This paper explores the legal and factual background to the new legislation on protecting water quality in Europe and takes a critical look at its most important provisions.

Sign in / Sign up

Export Citation Format

Share Document