The Concept of Soluble Residual Product Formation in the Modelling of Activated Sludge

1989 ◽  
Vol 21 (4-5) ◽  
pp. 339-350 ◽  
Author(s):  
D. Orhon ◽  
N. Artan ◽  
Y. Cimşit
Keyword(s):  
Organic Matter ◽  
Activated Sludge ◽  
Product Formation ◽  
Cellular Materials ◽  
Batch Reactors ◽  
Sequencing Batch Reactors ◽  
Soluble Organic Matter ◽  
Residual Product ◽  
Hydrolysis Of ◽  
Activated Sludge Systems

The soluble effluent COD of a well operated activated sludge plant is likely to be composed almost entirely of organic matter generated by microbial activity. There is evidence to show that a significant portion of this soluble organic matter is non-degradable and may be due to similar microbial mechanisms. A model for the formation of these soluble residual products, (SRP), is propose'd, relating the SRP formation to the hydrolysis of non-viable cellular materials in the reactor. The set of equations describing the model are successfully calibrated and verified for a set of representative experimental data derived from Sequencing Batch Reactors. The model is found to explain and predict COD accumulation at the end of each cycle of these activated sludge systems.

Study of factors affecting simultaneous nitrification and denitrification (SND)

1999 ◽  
Vol 39 (6) ◽  
pp. 61-68 ◽  
Author(s):  
Klangduen Pochana ◽  
Jürg Keller
Keyword(s):  
Carbon Source ◽  
Activated Sludge ◽  
Physical Phenomenon ◽  
Treatment Plant ◽  
Batch Reactors ◽  
Sequencing Batch Reactors ◽  
Factors Affecting ◽  
Floc Size ◽  
Sludge Flocs ◽  
Activated Sludge Systems

Experiments have been performed to gain an understanding of the conditions and processes governing the occurrence of SND in activated sludge systems. Sequencing batch reactors (SBRs) have been operated under controlled conditions using the wastewater from the first anaerobic pond in an abattoir wastewater treatment plant. Under specific circumstances, up to 95% of total nitrogen removal through SND has been found in the system. Carbon source and oxygen concentrations were found to be important process parameters. The addition of acetate as an external carbon source resulted in a significant increase of SND activity in the system. Stepwise change of DO concentration has also been observed in this study. Experiments to determine the effect of the floc size on SND have been performed in order to test the hypothesis that SND is a physical phenomenon, governed by the diffusion of oxygen into the activated sludge flocs. Initial results support this hypothesis but further experimental confirmation is still required.

Stress protein expression in domestic activated sludge in response to xenobiotic shock loading

2001 ◽  
Vol 43 (1) ◽  
pp. 123-130 ◽  
Author(s):  
C. B. Bott ◽  
A. J. Duncan ◽  
N. G. Love
Keyword(s):  
Activated Sludge ◽  
Shock Loading ◽  
Treatment Process ◽  
Stress Proteins ◽  
Stress Protein ◽  
Batch Reactors ◽  
Sequencing Batch Reactors ◽  
Analysis Method ◽  
Consistent Increase ◽  
Activated Sludge Systems

Using the Western blot immunochemical analysis method, the heat shock protein, GroEL, was found to be either induced or repressed in activated sludge microorganisms exposed to a range of xenobiotics. At the EC25 concentration, pentachlorophenol (PCP), cadmium, nickel, 2,4-dichloroaniline, benzoquinone, 2,4-dinitrophenol, and 1,1,1-trichloroethane all rapidly induced measurable GroEL expression, even though the time-dependent response for each of these compounds was somewhat varied. Toluene and hydroquinone resulted in repression of GroEL expression to levels below that measured in the control mixed liquor. For PCP concentrations at or exceeding the EC25, there was a significant and consistent increase in effluent volatile suspended solids from activated sludge sequencing batch reactors relative to unstressed controls. These preliminary results indicate that stress proteins may serve as sensitive and rapid indicators of toxicity which can adversely impact treatment process performance in activated sludge systems.

The Use of Anoxic Selectors for the Control of Low F/M Activated Sludge Bulking

1989 ◽  
Vol 21 (6-7) ◽  
pp. 609-619 ◽  
Author(s):  
Y.-J. Shao ◽  
David Jenkins
Keyword(s):  
Organic Matter ◽  
Activated Sludge ◽  
Pilot Plant ◽  
Detention Time ◽  
Substrate Removal ◽  
Batch System ◽  
Sludge Bulking ◽  
N Removal ◽  
Soluble Substrate ◽  
Activated Sludge Systems

Laboratory and pilot plant experiments on anoxic selector activated sludge systems were conducted on two wastewaters in some cases supplemented with nitrate, acetate or glucose. To prevent bulking sufficient anoxic selector detention time and nitrate levels must be available to reduce selector effluent soluble COD to below 100 mg/l and to reduce readily metabolizable organic matter to virtually zero (< 1 mg/l). Soluble COD/NO3-N removal stoichiometry is in the range 6.0-6.7. Selector systems have elevated soluble substrate removal and denitrification rates compared to CSTR systems. These rates are not affected greatly by temperature (20-25°C) for CSTR sludges but are for selector sludges. Upon exhaustion of nitrate in a selector soluble COD leaks out of the activated sludge in significant amounts. Thiothrix sp. and type 021N denitrify only to NO2 and at much slower rates than Zoogloearamigera does to N2. A sequencing batch system provides an optimistic estimate of the SVI that can be obtained by an anoxic selector system.

scholarly journals Influent with Particulate Substrate, Clean, Innocuous and Sustainable Solution for Bulking Control and Mitigation in Activated Sludge Process

Water ◽  
2021 ◽  
Vol 13 (7) ◽  
pp. 984
Author(s):  
Pedro Cisterna-Osorio ◽  
Claudia Calabran-Caceres ◽  
Giannina Tiznado-Bustamante ◽  
Nataly Bastias-Toro
Keyword(s):  
Activated Sludge ◽  
Suspended Solids ◽  
Nutrient Deficiency ◽  
Microscopic Analysis ◽  
Volume Index ◽  
Favorable Effect ◽  
Batch Reactors ◽  
Sequencing Batch Reactors ◽  
Active Sludge ◽  
Chemical Reagents

This research studies the incidence of the type of substrate, soluble or particulate, in the emergence, development, and inhibition of bulking in activated sludge systems. It was evaluated using the sludge volume index (SVI), mixing liquor-suspended solids (MLSS), microscopic analysis of biomass, and effluent suspended solids (ESS). In the first experiment, four sequencing batch reactors (SBRs) were fed with soluble substrate at a fixed mass, while the mass of the particulate substrate varied, as those (saccharose mass/flour mass) ratios were 3:1, 3:2, 3:3 and 3:4., with a deficit ranging from 20 to 30% compared to the ratio recommended. The four SBRs have similar MLSS, IVL, and ESS. From day 30, with a deficit from 80 to 90%, the influents have ratios 1/1 and 1/2 until 48 days. The SBRs present IVL between 600 and 730 mL/g and ESS from 370 to 440 mg/L; unlike influents with ratios 1/3 and 1/4, they present IVL between 170 and 185 mL/g, and ESS from 260 to 270 mg/L. The favorable effect of particulate matter is categorical. In the second set of experiments, two SBRs were studied: SBR 1 fed with saccharose, and SBR 2 with flour; there is a lack of nutrients causing bulking in SBRs. Once the nutrient deficiency condition is changed in day 11 to excess, after 22 days, the SVI was 190 mL/g, ESS was 360 mg/L, and MLSS was 2000 mg/L for influents with saccharose; the influent with flour, with an SVI of 80 mL/g, ESS of 100 mg/L, and MLSS of 4000 mg/L, shows faster and more consistent recovery with the particulate substrate. Therefore, the proposal is to add particulate substrate-like flour to active sludge plants facing bulking. It is a clean, innocuous and sustainable alternative to processes that use chemical reagents.

Wastewater fermentation and nutrient removal in sequencing batch reactors

1998 ◽  
Vol 38 (1) ◽  
pp. 255-264 ◽  
Author(s):  
Germán Cuevas-Rodríguez ◽  
Óscar González-Barceló ◽  
Simón González-Martínez
Keyword(s):  
Activated Sludge ◽  
Volatile Fatty Acids ◽  
Organic Load ◽  
Batch Reactors ◽  
Sequencing Batch Reactors ◽  
Organic Loading ◽  
Nitrogen And Phosphorus ◽  
Loading Rates ◽  
Average Value ◽  
Experimental Runs

This research project was conducted to analyze the performance of a SBR reactor when being fed with anaerobically fermented wastewater. Important was to determine the capacity of the system to remove nitrogen and phosphorus. Two SBR reactors, each one with a volume of 980 liters, were used: one used as fermenter and the other as activated sludge SBR. Using 8-hour cycles, the reactors were operated and studied during 269 days. The fermenter produced an effluent with an average value of 223±24 mg/l of volatile fatty acids. The activated sludge SBR was tested under 3 organic loading rates of 0.13, 0.25, and 0.35 kgCODtotal/kgTSS·d. For the three tested organic loading rates, PO4-P concentrations under 1.1 mg/l and COD between 37 and 38 mg/l were consistently achieved. Exceptionally high NH4-N influent values were measured during the time of the experimentation with the organic load of 0.25 kgCODtotal/kgTSS·d, not reaching in this case full nitrification. Denitrification was observed during the fill phase in every cycle. SVI values between 40 and 70 were determined during the experimental runs.

Characterization and Source of Trihalomethane Formation in the Secondary Effluent by Sequencing Batch Reactors

2013 ◽  
Vol 316-317 ◽  
pp. 323-326
Author(s):  
Chao Jie Zhang ◽  
Si Bo Li ◽  
Qian Chen ◽  
Qi Zhou
Keyword(s):  
Organic Matter ◽  
Activated Carbon ◽  
Dissolved Organic Matter ◽  
Secondary Effluent ◽  
Batch Reactors ◽  
Sequencing Batch Reactors ◽  
Human Beings ◽  
By Products

Dissolved organic matter (DOM) may do harms to human beings. After disinfected by chlorine (amine), DOM can form disinfection by-products (DBPs) which can be mutagenic, teratogenic and carcinogenic. Characterization and source of trihalomethane precursors in the secondary effluent by sequencing batch reactors were investigated. CHCl3 was the primary DBPs. The results showed that the precursors of CHCl3 were mainly strongly hydrophobic DOM, while CHCl2Br and CHClBr2 were mainly formed from hydrophilic DOM. The effects of different powder media (activated carbon, zeolite) on removal of DOM were compared. The results showed that the dosing of powder media can promote the removal of DOM and the DBPs precursors.

scholarly journals Contribution of prokaryotes and eukaryotes to CO2 emissions in the wastewater treatment process

PeerJ ◽  
2020 ◽  
Vol 8 ◽  
pp. e9325
Author(s):  
Katarzyna Jaromin-Gleń ◽  
Roman Babko ◽  
Tatiana Kuzmina ◽  
Yaroslav Danko ◽  
Grzegorz Łagód ◽  
...  
Keyword(s):  
Wastewater Treatment ◽  
Activated Sludge ◽  
Greenhouse Effect ◽  
Wastewater Treatment Plants ◽  
Ghg Emissions ◽  
Batch Reactors ◽  
Sequencing Batch Reactors ◽  
Wastewater Treatment Process ◽  
Eukaryotic Organisms ◽  
Quantitative Contribution

Reduction of the greenhouse effect is primarily associated with the reduction of greenhouse gas (GHG) emissions. Carbon dioxide (CO2) is one of the gases that increases the greenhouse effect - it is responsible for about half of the greenhouse effect. Significant sources of CO2 are wastewater treatment plants (WWTPs) and waste management, with about 3% contribution to global emissions. CO2 is produced mainly in the aerobic stage of wastewater purification and is a consequence of activated sludge activity. Although the roles of activated sludge components in the purification process have been studied quite well, their quantitative contribution to CO2 emissions is still unknown. The emission of CO2 caused by prokaryotes and eukaryotes over the course of a year (taking into account subsequent seasons) in model sequencing batch reactors (SBR) is presented in this study. In this work, for the first time, we aimed to quantify this contribution of eukaryotic organisms to total CO2 emissions during the WWTP process. It is of the order of several or more ppm. The contribution of CO2 produced by different components of activated sludge in WWTPs can improve estimation of the emissions of GHGs in this area of human activity.

scholarly journals Seasonal Dynamics of the Activated Sludge Microbiome in Sequencing Batch Reactors, Assessed Using 16S rRNA Transcript Amplicon Sequencing

2020 ◽  
Vol 86 (19) ◽  
Author(s):  
Juliet Johnston ◽  
Sebastian Behrens
Keyword(s):  
Wastewater Treatment ◽  
Microbial Community ◽  
16S Rrna ◽  
Activated Sludge ◽  
Seasonal Dynamics ◽  
Activity Patterns ◽  
Amplicon Sequencing ◽  
Batch Reactors ◽  
Sequencing Batch Reactors ◽  
Copy Numbers

ABSTRACT Activated sludge is comprised of diverse microorganisms which remediate wastewater. Previous research has characterized activated sludge using 16S rRNA gene amplicon sequencing, which can help to address questions on the relative abundance of microorganisms. In this study, we used 16S rRNA transcript sequencing in order to characterize “active” populations (via protein synthesis potential) and gain a deeper understanding of microbial activity patterns within activated sludge. Seasonal abundances of individual populations in activated sludge change over time, yet a persistent group of core microorganisms remains throughout the year which are traditionally classified on presence or absence without monitoring of their activity or growth. The goal of this study was to further our understanding of how the activated sludge microbiome changes between seasons with respect to population abundance, activity, and growth. Triplicate sequencing batch reactors were sampled at 10-min intervals throughout reaction cycles during all four seasons. We quantified the gene and transcript copy numbers of 16S rRNA amplicons using real-time PCR and sequenced the products to reveal community abundance and activity changes. We identified 108 operational taxonomic units (OTUs) with stable abundance, activity, and growth throughout the year. Nonproliferating OTUs were commonly human health related, while OTUs that showed seasonal abundance changes have previously been identified as being associated with floc formation and bulking. We observed significant differences in 16S rRNA transcript copy numbers, particularly at lower temperatures in winter and spring. The study provides an analysis of the seasonal dynamics of microbial activity variations in activated sludge based on quantifying and sequencing 16S rRNA transcripts. IMPORTANCE Sequencing batch reactors are a common design for wastewater treatment plants, particularly in smaller municipalities, due to their low footprint and ease of operations. However, like for most treatment plants in temperate/continental climates, the microbial community involved in water treatment is highly seasonal and its biological processes can be sensitive to cold temperatures. The seasonality of these microbial communities has been explored primarily in conventional treatment plants and not in sequencing batch reactors. Furthermore, most studies often only address which organisms are present. However, the activated sludge microbial community is very diverse, and it is often hard to discern which organisms are active and which organisms are simply present. In this study, we applied additional sequencing techniques to also address the issues of which organisms are active and which organisms are growing. By addressing these issues, we gained new insights into seasonal microbial populations dynamics and activity patterns affecting wastewater treatment.

Difficulties and developments in biological nutrient removal technology and modelling

1999 ◽  
Vol 39 (6) ◽  
pp. 1-11 ◽  
Author(s):  
George A. Ekama ◽  
Mark C. Wentzel
Keyword(s):  
Activated Sludge ◽  
Nutrient Removal ◽  
P Uptake ◽  
Biological Nutrient Removal ◽  
Filamentous Bulking ◽  
Recent Developments ◽  
Removal Technology ◽  
Hydrolysis Of ◽  
Activated Sludge Systems ◽  
P Removal

Filamentous bulking and the long sludge age required for nitrification are two important factors that limit the wastewater treatment capacity of biological nutrient removal (BNR) activated sludge systems. A growing body of observations from full-scale plants indicate support for the hypothesis that a significant stimulus for filamentous bulking in BNR systems in alternating anoxic-aerobic conditions with the presence of oxidized nitrogen at the transition from anoxic to aerobic. In the DEPHANOX system, nitrification takes place externally allowing sludge age and filamentous bulking to be reduced and increases treatment capacity. Anoxic P uptake is exploited in this system but it appears that this form of biological excess P removal (BEPR) is significantly reduced compared with aerobic P uptake in conventional BNR systems. Developments in the understanding of the BEPR processes of (i) phosphate accumulating organism (PAO) denitrification and anoxic P uptake, (ii) fermentation of influent readily biodegradable (RB)COD and (iii) anaerobic hydrolysis of slowly biodegradable (SB)COD are evaluated in relation to the IAWQ Activated Sludge Model (ASM) No.2. Recent developments in BEPR research do not yet allow a significant improvement to be made to ASM No. 2 that will increase its predictive power and reliability and therefore it remains essentially as a framework to guide further research.

Sign in / Sign up

Export Citation Format

Share Document