scholarly journals OPTIMIZATION OF TECHNOLOGICAL PARAMETERS IN THE SPRAY DRYING OF COCONUT MILK POWDER WITH HIGH FAT CONTENT

2009 ◽  
Vol 12 (4) ◽  
pp. 68-74 ◽  
Author(s):  
Man Van Viet Le ◽  
Minh Van Vuong
Keyword(s):  
Spray Drying ◽  
Design Method ◽  
Milk Powder ◽  
Dry Weight ◽  
Fat Content ◽  
Coconut Milk ◽  
High Fat ◽  
Technological Parameters ◽  
Feed Concentration ◽  
Rotary Speed

This research focuses on the spray drying of coconut milk powder with high fat content (50% of dry weight). The spray drying was carried out by Mobile Minor TM 2002 systems (Niro, Denmark). The influence of different technological parameters on the spray drying was examined. The central composite design method was used for operation optimization. Some optimal technological parameters of the spray drying were as follows: feed concentration: 24% weight/ weight (w/w); inlet and outlet temperatures of drying agent: 155+2°C and 75+2°C, respectively; pump rate of feed: 1.6L/h and rotary speed of atomizer: 20.000rpm. In these conditions, the product recovery yield was 82.2%.

Effect of Spray Drying Air Temperature to the Changes of Properties of Skimmed Coconut Milk Powder

2020 ◽  
Author(s):  
Jaruwan Duangchuen ◽  
Siwalak Pathaveerat ◽  
Sirinad Noypitak ◽  
Phiraiwan Jermwongruttanachai
Keyword(s):  
Spray Drying ◽  
Air Temperature ◽  
Milk Powder ◽  
Coconut Milk

scholarly journals The Effect of Different Type Drying Methods on Chemical Characteristics and Microbiology of Goat Milk Powder Kefir

2020 ◽  
Vol 7 (1) ◽  
Author(s):  
Nurwantoro Nurwantoro ◽  
Siti Susanti ◽  
Heni Rizqiati
Keyword(s):  
Water Content ◽  
Spray Drying ◽  
Milk Powder ◽  
Goat Milk ◽  
Fat Content ◽  
Ash Content ◽  
Chemical Characteristics ◽  
Drying Method ◽  
Total Acid ◽  
Total Yeast

The research aims to test and compare the chemical characteristics and total Lactic Acid Bacteria or LAB of goat milk powder kefir that was produced from cabinet drying, freeze drying and spray drying. Kefir was made from goat milk since it was found as a good digestibility, no β-lactoglobulin, and high protein. Data analysis was performed with the test analysis of variance with a significance level of 5% followed by Duncan testing if significant result was detected. Analysis of total acid was conducted using titration. Analysis of proteins was conducted using Kjeldahl method. Water content analysis was performed using oven and ash content was analyzed using furnace. Analysis of fat content was conducted using Soxhlet method. Analysis of total LAB and total yeast were done using Total Plate Count (TPC). As results, drying method significantly affected (p<0.05) water content, ash content, and total LAB but there was no significant effect (p<0.05) on the total acid, protein content, fat content, and total yeast. As conclusion, the best treatment of drying method in making goat milk kefir powder was spray drying

scholarly journals Devising optimal technological parameters for spray drying to produce whole camel milk powder

2021 ◽  
Vol 4 (11(112)) ◽  
pp. 82-91
Author(s):  
Nurbek Aralbayev ◽  
Fatima Dikhanbayeva ◽  
Yus Aniza Binti Yusof ◽  
Aigul Tayeva ◽  
Zhuldyz Smailova
Keyword(s):  
Moisture Content ◽  
Spray Drying ◽  
Water Activity ◽  
Air Temperature ◽  
Feed Rate ◽  
Milk Powder ◽  
Camel Milk ◽  
Milk Product ◽  
Technological Parameters ◽  
Study Results

Camel milk is a valuable source of protein and nutrients, it has therapeutic and prophylactic properties. The production of dry dairy products based on camel milk implies prolonging its shelf life, a decrease in the cost of its transportation and storage. To manufacture dry camel milk, it is necessary to optimize the technological parameters of drying, which affect its physical-chemical properties. Whole milk from camels (Camelus dromedarius) was dried on a spray drying plant under the following modes: the inlet temperature from 140 °C to 160 °C; the feed rate from 30 ml/min to 40 ml/min. The dependence of such physical properties of milk powder as the water solubility index, water absorption index, moisture content, hygroscopicity, density, water activity, the stickiness and size of particles on the technological parameters of drying has been established. The study results show that the highest index of solubility of samples was equal to 81.25±0.11 %, which corresponded to the air temperature at the inlet of 150 °C and the feed rate of 30 ml/min. At the same time, the lowest solubility was 62.89±0.27 % under the modes of 140 and 40 ml/min, respectively. With an increase in the air temperature at the inlet and a decrease in the rate of supply of dairy raw materials, there was a decrease in the moisture content and water activity. However, an increase in the air temperature at the inlet above 150 °C led to a decrease in the solubility index in water. The optimal particle sizes of whole camel milk powder, preceding a relatively high solubility index, were 36.22±0.33 μm, 108.89±0.56 μm, and 229.19±0.74 μm. The data reported in this paper could be useful in devising the technology for manufacturing a dry milk product from camel milk.

Non-Fasting Factor VII Coagulant Activity (FVII:C) Increased by High-Fat Diet

1994 ◽  
Vol 71 (06) ◽  
pp. 755-758 ◽  
Author(s):  
E M Bladbjerg ◽  
P Marckmann ◽  
B Sandström ◽  
J Jespersen
Keyword(s):  
High Fat Diet ◽  
Fat Content ◽  
Factor Vii ◽  
Amidolytic Activity ◽  
High Fat ◽  
Low Fat Diet ◽  
Increased Risk ◽  
Coagulant Activity ◽  
High Fat Diets ◽  
Fat Diets

SummaryPreliminary observations have suggested that non-fasting factor VII coagulant activity (FVII:C) may be related to the dietary fat content. To confirm this, we performed a randomised cross-over study. Seventeen young volunteers were served 2 controlled isoenergetic diets differing in fat content (20% or 50% of energy). The 2 diets were served on 2 consecutive days. Blood samples were collected at 8.00 h, 16.30 h and 19.30 h, and analysed for triglycerides, FVII coagulant activity using human (FVII:C) or bovine thromboplastin (FVII:Bt), and FVII amidolytic activity (FVIPAm). The ratio FVII:Bt/FVII:Am (a measure of FVII activation) increased from fasting levels on both diets, but most markedly on the high-fat diet. In contrast, FVII: Am (a measure of FVII protein) tended to decrease from fasting levels on both diets. FVII:C rose from fasting levels on the high-fat diet, but not on the low-fat diet. The findings suggest that high-fat diets increase non-fasting FVII:C, and consequently may be associated with increased risk of thrombosis.

BIOASSAY OF PROLACTIN

1969 ◽  
Vol 60 (1) ◽  
pp. 91-100 ◽  
Author(s):  
Charles S. Nicoll
Keyword(s):  
Epithelial Cells ◽  
Lipid Content ◽  
Dry Weight ◽  
Fat Content ◽  
Assay Sensitivity ◽  
Mucosal Epithelium ◽  
Wet Weight ◽  
Total Dry Weight

ABSTRACT The response of the pigeon crop-sac to systemically acting prolactin (injected subcutaneously) was evaluated by measuring the wet weight of the responsive lateral lobes of the organ and by determining the dry weight of a 4 cm diameter disc of mucosal epithelium taken from one hemicrop. Of several different injection schedules tested, administration of prolactin in four daily injections was found to yield optimal responses. When compared with a graded series of prolactin doses, measurement of the mucosal dry weight proved to be a better method of response quantification than determination of the crop-sac wet weight with respect to both assay sensitivity and precision. The submucosal tissue of the crop-sac was estimated to constitute about 64 % of the total dry weight of the unstimulated organ and it was found to be relatively unresponsive to prolactin stimulation in comparison with the mucosa. The lipid content of the mucosal epithelium was determined using unstimulated crop-sacs or tissues which showed varying degrees of prolactin-induced proliferation. The fat content of the mucosal epithelial cells increased only slightly more rapidly than the dry weight or the defatted dry weight of the mucosa. Suggestions are made for the further improvement of the systemic crop-sac assay for prolactin.

scholarly journals The effect of meal composition on the degree of satiation following a test meal and possible mechanisms involved

1988 ◽  
Vol 60 (3) ◽  
pp. 441-449 ◽  
Author(s):  
Christopher J. I. Driver
Keyword(s):  
Time Course ◽  
Dry Weight ◽  
High Fat ◽  
Point Scale ◽  
Protein Meal ◽  
Low Protein ◽  
Gut Hormone ◽  
High Protein Meal ◽  
Milk Solids ◽  
Meal Composition

1. Possible links between metabolism and satiation were investigated using volunteer subjects given test meals based on milk solids. Satisfaction was rated by the subjects on a six-point scale and the course of metabolism was followed by measurement of the respiratory quotient (RQ).2. The time-course of satiation was the same for a high-carbohydrate, a high-fat and a high-protein meal, in spite of the very different time-course of metabolism. The degree of satiation was reduced by added sodium chloride, without affecting the RQ rise. On the other hand, calcium chloride produced a suppression of the RQ rise without altering the satiation.3. It is proposed that the results indicate that the primary receptors responsible for post-prandial satiation lie within the gut wall and that there is probably a number of receptor types. Likely candidates for these receptors are the gut hormone-secreting cells.4. Although very-low-protein meals produce less satiation than meals containing 220 g protein/kg dry weight, there is no additional satiation obtained by increasing the protein level further. This is not inconsistent with the possibility of a protein hunger separate from an energy hunger.

DRIED MILK POWDER: II. FACTORS AFFECTING THE SORPTION OF CARBON DIOXIDE

1945 ◽  
Vol 23f (6) ◽  
pp. 327-333 ◽  
Author(s):  
Jesse A. Pearce
Keyword(s):  
Carbon Dioxide ◽  
Milk Powder ◽  
Sorption Rate ◽  
High Fat ◽  
Time Intervals ◽  
Sorption Behaviour ◽  
Factors Affecting ◽  
Whole Milk ◽  
Identical Manner ◽  
Whole Milk Powder

Sorption of carbon dioxide by milk powder in a closed system at 35 °C. and at approximately 74 cm. of mercury was observed to be greater than 0.4 cc. per gm. after 150 hr., while only 0.012 cc. of nitrogen was absorbed per gm. after 70 hr. The initial sorption of carbon dioxide varied with time according to the equation:[Formula: see text]where s is 100 times the amount sorbed in cc. per gm. at any time, t (min.), and k and m are constants peculiar to the system under investigation. The logarithmic form of this equation was used. Powders with 26, 28, and 30% fat did not differ in behaviour, but sorption curves for powders with only 1% fat had lower [Formula: see text] values and lower [Formula: see text] values than the curves for the high fat levels. Powders with 1% fat sorbed carbon dioxide in an identical manner when exposed to either 100% carbon dioxide or a mixture of 20% carbon dioxide and 80% nitrogen. For whole milk powder, dilution to 80% nitrogen content was effective in reducing the initial sorption rate of carbon dioxide. Great variation was observed in the sorption behaviour of powders from different plants and in powders produced at different time intervals in the same plant. Temperature differences within the range 25° to 40 °C. had no effect on sorption. Palatability and [Formula: see text] correlated to the extent of r =.61.

scholarly journals Staphylococcal Food Poisoning Associated with Spray-Dried Milk

1955 ◽  
Vol 53 (4) ◽  
pp. 387-397 ◽  
Author(s):  
P. H. R. Anderson ◽  
Doris M. Stone
Keyword(s):  
Spray Drying ◽  
Clinical Features ◽  
Milk Powder ◽  
Food Poisoning ◽  
Skim Milk ◽  
Skim Milk Powder ◽  
Large Numbers ◽  
Heat Treated ◽  
Drying Chamber ◽  
Spray Dried

SummaryEight explosive outbreaks of food poisoning, occurring in school canteens in England during 1953 and affecting 1190 known cases, are described. The clinical features were characteristic of the toxin type of illness. No deaths occurred.The food causing all of these outbreaks was prepared from spray-dried skim milk powder. It was not subsequently heat-treated and was usually consumed 3–4 hr. after preparation.The spray-dried milk powder proved to contain a high content of bacteria, including large numbers of Staph. aureus, of a phage pattern often associated with food poisoning. The assumption was therefore made that these outbreaks were caused by staphylococcal enterotoxin.Because the food was often consumed within 3–4 hr. of reconstitution of the milk powder—before, in fact, the staphylococci had had time to grow—it is concluded that the poisoning must have been due mainly to pre-formed toxin.Consideration is given to the opportunities for the formation of toxin in a spray-drying plant, and reasons are brought forward for believing that it is formed mainly in the balance tank where the warm milk is kept, sometimes for several hours, before passing into the final drying chamber.The processing of the milk and the precautions for preventing contamination of the finished product are discussed.

scholarly journals Regulation of plasma leptin in mice: influence of age, high-fat diet, and fasting

1997 ◽  
Vol 273 (1) ◽  
pp. R113-R120 ◽  
Author(s):  
B. Ahren ◽  
S. Mansson ◽  
R. L. Gingerich ◽  
P. J. Havel
Keyword(s):  
Body Weight ◽  
Dietary Fat ◽  
High Fat Diet ◽  
Plasma Insulin ◽  
Plasma Concentrations ◽  
Age Groups ◽  
Fat Content ◽  
High Fat ◽  
Background Strain ◽  
Plasma Leptin

Mechanisms regulating circulating leptin are incompletely understood. We developed a radioimmunoassay for mouse leptin to examine the influence of age, dietary fat content, and fasting on plasma concentrations of leptin in the background strain for the ob/ob mouse, the C57BL/6J mouse. Plasma leptin increased with age [5.3 +/- 0.6 ng/ml at 2 mo (n = 23) vs. 14.2 +/- 1.6 ng/ml at 11 mo (n = 15), P < 0.001]. Across all age groups (2-11 mo, n = 160), log plasma leptin correlated with body weight (r = 0.68, P < 0.0001), plasma insulin (r = 0.38, P < 0.001), and amount of intra-abdominal fat (r = 0.90, P < 0.001), as revealed by magnetic resonance imaging. Plasma leptin was increased by a high-fat diet (58% fat for 10 mo) and reduced by fasting for 48 h. The reduction of plasma leptin was correlated with the reduction of plasma insulin (r = 0.43, P = 0.012) but not with the initial body weight or the change in body weight. Moreover, the reduction in plasma leptin by fasting was impaired by high-fat diet. Thus plasma leptin in C57BL/6J mice 1) increases with age or a high-fat diet; 2) correlates with body weight, fat content, and plasma insulin; and 3) is reduced during fasting by an action inhibited by high-fat diet and related to changes of plasma insulin.

Sign in / Sign up

Export Citation Format

Share Document