Evaluation of Biogas Production from Bio-Digestion of Organic Wastes

2020 ◽  
Vol 51 ◽  
pp. 217-227
Author(s):  
Oludare Johnson Odejobi ◽  
Oluwagbenga Abiola Olawuni ◽  
Samuel Olatunde Dahunsi ◽  
Akinbiyi Ayomikusibe John
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Organic Wastes ◽  
Methane Content ◽  
Composition Analysis ◽  
Cow Dung ◽  
Biogas Yield ◽  
Animal Manures ◽  
Ph Range ◽  
Poultry Droppings

The present study evaluates the influence of kitchen wastes on animal manures via anaerobic digestion for biogas production. The digestion was done using a digester with a capacity of 5L. The digester was loaded with the slurry of wastes prepared by mixing the wastes with water in ratio 1:1, and operated at mesophilic temperature of 37 ± 2°C for 30 days. The co-digestion of kitchen wastes with poultry droppings produced highest biogas yield (814.0 ml/kg VS fed) and the least (365.84 ml/kg VS fed) was from the co-digestion of kitchen wastes with the mixture of poultry droppings and cow dung. Composition analysis of the biogas showed the highest methane content (63.1%) from kitchen wastes and the lowest (56.2%) from co-digestion of kitchen wastes with poultry droppings. The pH range for optimum biogas production varied between 5.25 and 7.5. The study concluded that biogas yield from co-digestion of substrates, among other factors depends on the composition of participating substrates.

scholarly journals Evaluation of Anaerobic Digestion of Dairy Wastewater in an Innovative Multi-Section Horizontal Flow Reactor

Energies ◽  
2020 ◽  
Vol 13 (9) ◽  
pp. 2392 ◽  
Author(s):  
Marcin Dębowski ◽  
Marcin Zieliński ◽  
Marta Kisielewska ◽  
Joanna Kazimierowicz
Keyword(s):  
Wastewater Treatment ◽  
Anaerobic Digestion ◽  
Flow Reactor ◽  
Biogas Production ◽  
Oxygen Demand ◽  
Methane Content ◽  
Dairy Wastewater ◽  
Horizontal Flow ◽  
Organic Loading Rate ◽  
Biogas Yield

The aim of this study was the performance evaluation of anaerobic digestion of dairy wastewater in a multi-section horizontal flow reactor (HFAR) equipped with microwave and ultrasonic generators to stimulate biochemical processes. The effects of increasing organic loading rate (OLR) ranging from 1.0 g chemical oxygen demand (COD)/L·d to 4.0 g COD/L·d on treatment performance, biogas production, and percentage of methane yield were determined. The highest organic compounds removals (about 85% as COD and total organic carbon—TOC) were obtained at OLR of 1.0–2.0 g COD/L·d. The highest biogas yield of 0.33 ± 0.03 L/g COD removed and methane content in biogas of 68.1 ± 5.8% were recorded at OLR of 1.0 g COD/L·d, while at OLR of 2.0 g COD/L·d it was 0.31 ± 0.02 L/COD removed and 66.3 ± 5.7%, respectively. Increasing of the OLR led to a reduction in biogas productivity as well as a decrease in methane content in biogas. The best technological effects were recorded in series with an operating mode of ultrasonic generators of 2 min work/28 min break. More intensive sonication reduced the efficiency of anaerobic digestion of dairy wastewater as well as biogas production. A low nutrient removal efficiency was observed in all tested series of the experiment, which ranged from 2.04 ± 0.38 to 4.59 ± 0.68% for phosphorus and from 9.67 ± 3.36 to 20.36 ± 0.32% for nitrogen. The effects obtained in the study (referring to the efficiency of wastewater treatment, biogas production, as well as to the results of economic analysis) proved that the HFAR can be competitive to existing industrial technologies for food wastewater treatment.

scholarly journals Opportunity of Biogas Production from Solid Organic Wastes through Anaerobic Digestion

2018 ◽  
Vol 65 ◽  
pp. 05025 ◽  
Author(s):  
Sagor Kumar Pramanik ◽  
Fatihah Binti Suja ◽  
Biplob Kumar Pramanik ◽  
Shahrom Bindi Md Zain
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Nutrient Balance ◽  
Organic Wastes ◽  
Organic Loading Rate ◽  
Biogas Yield ◽  
Carbon And Nitrogen ◽  
Potential Risks ◽  
Nitrogen Ratio ◽  
Pre Treatment

Solid organic wastes create potential risks to environmental pollution and human health due to the uncontrolled discharge of huge quantities of hazardous wastes from numerous sources. Now-a-days, anaerobic digestion (AD) is considered as a verified and effective alternative compared to other techniques for treating solid organic waste. The paper reviewed the biological process and parameters involved in the AD along with the factors could enhance the AD process. Hydrolysis is considered as a rate-limiting phase in the complex AD process. The performance and stability of AD process is highly influenced by various operating parameters like temperature, pH, carbon and nitrogen ratio, retention time, and organic loading rate. Different pre-treatment (e.g. mechanical, chemical and biological) could enhance the AD process and the biogas yield. Co-digestion can also be used to provide suitable nutrient balance inside the digester. Challenges of the anaerobic digestion for biogas production are also discussed.

scholarly journals Performance of Anaerobic Digestion of Chicken Manure Under Gradually Elevated Organic Loading Rates

2019 ◽  
Vol 16 (12) ◽  
pp. 2239 ◽  
Author(s):  
Fei Wang ◽  
Mengfu Pei ◽  
Ling Qiu ◽  
Yiqing Yao ◽  
Congguang Zhang ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Poultry Manure ◽  
Ammonia Nitrogen ◽  
Methane Content ◽  
Chicken Manure ◽  
Continuous Stirred Tank Reactor ◽  
Organic Loading ◽  
Biogas Yield ◽  
Loading Rates

Poultry manure is the main source of agricultural and rural non-point source pollution, and its effective disposal through anaerobic digestion (AD) is of great significance; meanwhile, the high nitrogen content of chicken manure makes it a typical feedstock for anaerobic digestion. The performance of chicken-manure-based AD at gradient organic loading rates (OLRs) in a continuous stirred tank reactor (CSTR) was investigated herein. The whole AD process was divided into five stages according to different OLRs, and it lasted for 150 days. The results showed that the biogas yield increased with increasing OLR, which was based on the volatile solids (VS), before reaching up to 11.5 g VS/(L·d), while the methane content was kept relatively stable and maintained at approximately 60%. However, when the VS was further increased to 11.5 g VS/(L·d), the total ammonia nitrogen (TAN), pH, and alkalinity (CaCO3) rose to 2560 mg·L−1, 8.2, and 15,000 mg·L−1, respectively, while the volumetric biogas production rate (VBPR), methane content, and VS removal efficiency decreased to 0.30 L·(L·d)−1, 45%, and 40%, respectively. Therefore, the AD performance immediately deteriorated and ammonia inhibition occurred. Further analysis demonstrated that the microbial biomass yield and concentrations dropped dramatically in this period. These results indicated that the AD stayed steady when the OLR was lower than 11.5 g VS/(L·d); this also provides valuable information for improving the efficiency and stability of AD of a nitrogen-rich substrate.

Solid-State Anaerobic Digestion for Methane Production from Corn Stalks with Stack-Pretreated

2011 ◽  
Vol 697-698 ◽  
pp. 326-330 ◽  
Author(s):  
S.X. Zhou ◽  
Y.P. Dong ◽  
Y.L. Zhang
Keyword(s):  
Anaerobic Digestion ◽  
Solid State ◽  
Methane Production ◽  
Biogas Production ◽  
Cow Dung ◽  
Cow Manure ◽  
Pretreatment Method ◽  
Biogas Yield ◽  
Microbial Pretreatment ◽  
Microbial Strains

Microbial pretreatment was applied to enhance biogas production from corn stover through solid-state anaerobic digestion, but the price of microbial strains is high. The objective of this study was to find the effects on biogas production by the naturally microbial pretreatment method. The highest cumulative biogas yield for 60-day solid-state anaerobic digestion was obtained in B group (the pretreated corn straws with cow dung), which was 19.6% higher than that of the untreated samples. The D group（the pretreated corn straws with the sludge）cumulative biogas yield for 60-day solid-state anaerobic digestion was obtained, which was 18.87% higher than that of the untreted samples. The biogas of D group increased to the range of 55%～60% methane content, while B group with the range of 75%～80%.The results indicated that the pretreated corn straws mixing cow manure can improve both the biogas production yield and the content of methane in CH4。

scholarly journals Kinetic Study on Biogas Production from Cabbage (Brassica oleracea) Waste and Its Blend with Animal Manure Using Logistic Function Model

2021 ◽  
pp. 34-43
Author(s):  
Christian C. Opurum
Keyword(s):  
Anaerobic Digestion ◽  
Kinetic Parameters ◽  
Goodness Of Fit ◽  
Biogas Production ◽  
Logistic Function ◽  
Gas Production ◽  
Cow Dung ◽  
Function Model ◽  
Biogas Yield ◽  
Significant Difference

This research paper aimed to evaluate the kinetics of anaerobic digestion (AD) of mixtures of cabbage waste (CW) with (Poultry dropping (PD) and Cow dung (CD). The study was conducted in 10L bio-digesters for 35 days under mesophilic conditions (25 - 35OC). Logistic function equation was used to simulate the experimental data to test for its goodness of fit and kinetic parameters namely: maximum biogas potential (Pb), the maximum biogas production rate (Rm), and the lag phase duration (λ) were estimated in each treatment. Chemical analysis showed that individual substrates possess characteristics that could support microbial activities in biogas production. The biogas yield in terms of added  volatile solids (VS) in decreasing order was as follows: 0.022, 0.018, 0.017, 0.014, 0.014 and 0.013 dm3/g VS for CW/CD 2:1, CW/PD3:1, CW/CD 1:1, CW alone, CW/PD1:1 and  CW/PD 2:1, respectively. A significant difference (P ≤ 0.05) in biogas yield was recorded in CW/CD 2:1 with 7.19 dm3 (53.29% increase). The kinetic parameters (Pb, Rm, and λ) for CW/CD 2:1 was 7.01 dm3, 1.58 dm3.d, and 2.29 days, respectively. This was followed by CW/PD 3:1 (5.84 dm3); with 24.92% increase in gas production and CW/CD 1:1 (5.42 dm3) with 15.53% increase relative to CW alone, 4.69 dm3. The digesters fed with CW/PD 1:1 and CW/PD 2:1 exhibited inhibitory effects on biogas production, with 7.51 and 2.05% decrease in gas yield, respectively. The logistic function model demonstrated a strong relationship between the experimental and model-predicted data. The high correlation coefficient (R2) ranging between 0.978 - 0.993 is evident. The model proved to be a useful tool in predicting anaerobic digestion and biogas production process.

scholarly journals Investigation on mesophilic anaerobic co-digestion of community waste and cow dung: effect of operating parameters

2019 ◽  
Vol 4 (6) ◽  
Author(s):  
KO Ansah Amano ◽  
E Appiah-Danquah ◽  
E Adom ◽  
AG Ntiri-Asiedu ◽  
ES Amoamah ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Retention Time ◽  
Hydraulic Retention Time ◽  
Ph Value ◽  
Cow Dung ◽  
Waste Generation ◽  
Batch Mode ◽  
Biogas Yield ◽  
Digestion Process ◽  
Ph Range

Management of waste is a key concern in several communities in Ghana. The exponential growth in waste generation imposes serious threats such as environmental pollution, health risk and scarcity of dumping site to our society. A large variety of organic rich materials inherent in this waste have high potential to be treated by the use of anaerobic digestion. In this study, eight (8) Laboratory scale biodigesters were used for the anaerobic co-digestion of household and market waste with cow dung as inoculum, controlled at a pH range of 6.53-7.04 and at a mesophilic temperature of 35±2˚C. The study was also conducted in batch mode at a hydraulic retention time of 21 days. The anaerobic co-digestion process was developed and optimized at varying feedstock to inoculum ratio to determine the potential biogas yield from each proportion. The results obtained indicate sample S8, containing market waste and inoculum in the ratio of 6:1 produced the optimum concentration of methane (51% v/v biogas) while the least was recorded by sample S2 primarily made up of market waste. ANOVA results show that the concentration of methane produced from the substrate is significantly affected by the hydraulic retention time and pH value of the anaerobic digestion process.

Investigation of Biogas Production Using Organic Kitchen Wastes through Anaerobic Digestion

2015 ◽  
Vol 787 ◽  
pp. 97-101
Author(s):  
D. Thamilselvan ◽  
K. Arulkumar ◽  
M. Kannan
Keyword(s):  
Anaerobic Digestion ◽  
Fossil Fuels ◽  
Biogas Production ◽  
Renewable Resource ◽  
Biogas Plant ◽  
Cow Dung ◽  
Fermentation Time ◽  
Ph Variation ◽  
Biogas Yield ◽  
Oil Crisis

The present day’sresearch interests on bioenergy have been expanded rapidly due to oil crisis of 1980s. This bio energy should be available in locally and it’spurer than the fossil fuels. The field of bio energyis important for governments, scientists and business people in worldwide because of its available in nature and renewable resource. Todays the most important renewable energy is Biomass. The biological conversion of biomass to methane has become rapidly increasing in present days. All types of organic wastes can be converted to methane. In this study the installed plant is a sintex floating type biogas plant. The cubic capacity of plant is about 1000 liter. The pH range is maintained in the level of 6.8 to 7.5. The fermentation time of the anaerobic digestion for the efficient usage of gas as a fuel is about 30 days. Our biogas plant is used for all types of anaerobic respirating wastes such as cow dung manure, kitchen wastes etc.The input feed of kitchen waste is about 10 kg per day. The output of the biogas yield is about 0.714 m3/kg. The composition of biogas is 50% to 60% of methane and rather than remaining 30% to 40% CO2and small amount of water about 2% to 5%. The performance characteristics of biogas plant are studied in this paper. To evaluate the performance of biogas production and pH variation throughout this study.

scholarly journals Biogas production from cow dungs using a modified fixed-dome digester

2021 ◽  
Vol 7 (3) ◽  
pp. 224-230
Author(s):  
Mtamabari Simeon Torbira ◽  
Ebigenibo Genuine Saturday
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Total Solid ◽  
Cow Dung ◽  
Biogas Yield ◽  
Carbon To Nitrogen Ratio ◽  
Temperature Range ◽  
Nitrogen Ratio ◽  
Design And Construction

A modified fixed dome digester with stirring mechanism has been designed and constructed and used for the anaerobic digestion of cow dung slurry at 5%-7% Total solid (TS) concentration within the mesophylic temperature range. The quality of biogas gas produced was between 54%-69% methane (CH4) content. The Carbon to Nitrogen ratio (C: N) varied between 35:1 - 45:1. Total biogas yield obtained over the detention period was about 261 L. The maximum and minimum temperatures recorded over the 95 days period was 32oC and 25 oC respectively. The volume of biogas yield, Vb (m3) was observed to increase with the percentage total solid, PTS (%). The details of the design and construction of the biogas digester plant and its cost are reported. The performance of the plant was very satisfactory. Investigation into the anaerobic digestion revealed that cow dung has great potentials for generation of biogas.

scholarly journals Evaluation of Biogas through Chemically Treated Cottonseed Hull in Anaerobic Digestion with/without Cow Dung: An Experimental Study

2021 ◽  
Author(s):  
Venkateshkumar R ◽  
Shanmugam S ◽  
Veerappan AR
Keyword(s):  
Anaerobic Digestion ◽  
Sodium Hydroxide ◽  
Calcium Hydroxide ◽  
Biogas Production ◽  
Cow Dung ◽  
Batch Reactors ◽  
Biogas Yield ◽  
Cottonseed Hull ◽  
Pre Treatment ◽  
Feedstock Material

Abstract Cow dung is generally used as the feedstock material for the anaerobic digestion to produce biogas. A selection of alternate biomass material is needed to reduce the consumption or to eliminate the use of cow dung. Recently, cottonseed hull has been considered as the primary substrate to produce biogas. In this paper, the effect of biogas production on anaerobic co-digestion of cow dung with pre-treated cottonseed hull using different concentrations of sulfuric acid, hydrochloric acid, hydrogen peroxide, and acetic acid is investigated. Sodium hydroxide and calcium hydroxide are used at different concentrations for pre-treatment of cottonseed hull. The enhancement of biogas production from the batch reactors at mesophilic temperature (35 ± 2 ℃) is observed for mono- and co-digestion of cow dung with treated cottonseed hull. Maximum biogas yield is achieved for the treated cottonseed hull at 6% sodium hydroxide during mono digestion and at 6% calcium hydroxide during co-digestion.

scholarly journals Effects of Co-substrate Concentrations on the Anaerobic Co-Digestion of Common Reed and Cow Dung

2019 ◽  
Vol 3 (1) ◽  
pp. 28-32 ◽  
Author(s):  
Giang Van Tran ◽  
Yuwalee Unpaprom ◽  
Rameshprabu Ramaraj
Keyword(s):  
Large Scale ◽  
Biogas Production ◽  
Batch Reactor ◽  
Scale Up ◽  
Common Reed ◽  
Chemical Oxidation ◽  
Methane Content ◽  
Cow Dung ◽  
Biogas Yield ◽  
Working Volume

The biochemical methane potentials for common reed (Phragmites australis) and cow dung from northern Thailand, Chiang Mai city were investigated. This study aims to evaluate optimal parameters for the substrate of common reed and cow dung with different ratios (i.e. 1:1, 2:1 and 1:2) for improving the quality of methane content and biogas production. The effect of the co-substrate mixture was carried out in a batch reactor operated under room temperature and hydraulic retention time (HRT) of 45 days. The experiments were conducted in the fermenter with a working volume of 2.5 L and a total volume of 3L. The substrate was containing 15% of total solids (TS) and fermentation at initial pH 7. Biodegradation of substrate stated that chemical oxidation demand (COD) removal was 52.38%, the utilization of volatile solid was 75.46%. The results were achieved at ratio 2:1 (common reed and cow dung) reached the highest methane content and total biogas yield are 70% and 20,015 ml, respectively. Consequently, the results of this study suggested that mixing ratios of influence on the fermentation process and monitoring parameters were significant for further scale up or large-scale design of enriched methane content and biogas production.

Sign in / Sign up

Export Citation Format

Share Document