POSSIBILITIES OF DRIED DISTILLERS’ GRAINS WITH SOLUBLES APPLICATION IN FEED MIXTURES

The possibility of utilization of dried distiller’s grains with solubles (DDGS) in feed mixtures for feed production was investigated. Samples of maize hybrids ZP 548 and ZP 655b and DDGS obtained from hybrids ZP 548 and ZP 548c were used as components of the mixtures.The total protein content ranged from 12.42 % to 31.18 %, moisture from 5.49 % to 9.55 and ash content of 1.85 % to 4.37 %. The contents of NDF, ADF, ADL, hemicellulose and cellulose fibers ranged from: 13.90 % to 48.13 %; 2.96 % to 20.69 %; 0.27 % to 2.44 %; 10.69 % to 30.17 %, 2.62 % to 18.32 %, respectively. In vitro dry matter digestibility ranged from 55.20 % to 89.76 %. It was concluded that the samples of DDG obtained from red and yellow maize hybrids kernel are very suitable as components for the preparation of animal feed mixtures.

PSIV-2 A comparison of feedlot growth and performance of beef x Holstein crossbred steers and Holstein steers

Objectives were to compare feedlot performance and carcass traits of F1 beef × Holstein steers and Holstein steers. Angus or Limousin × Holstein crossbred [n = 27; age = 12 ± 3 months; body weight (BW) = 435 ± 8 kg] and Holstein (n = 20; age = 11 ± 2 months; BW = 400 ± 9 kg) steers were fed at the Pennsylvania Department of Agriculture Livestock Evaluation Center for 111 days. Feed intake was recorded using the GrowSafe Feed Intake Monitoring System (Model 4000E, GrowSafe Systems Ltd., Calgary AB, Canada). The diet contained corn silage, dried distillers grains, soybean meal, and cracked corn and was formulated to meet or exceed the requirements of beef cattle (NASEM, 2016). Growth performance variables of interest and carcass measurements were analyzed with the Mixed procedure of SAS (SAS 9.4; SAS Institute Inc., Cary, NC). USDA assigned quality grades (QG) and yield grades (YG) were analyzed the with GLIMMIX procedure of SAS. Breed was a fixed effect in all models. There were no differences (P > 0.05) between breeds in average daily gain or feed efficiency. Crossbreds exceeded Holsteins in initial (P < 0.01) and final BW (P = 0.01), dry matter intake (P = 0.03), hot carcass weight (P < 0.01), backfat (P = 0.03), and ribeye area (REA; P < 0.01). Thirty-five percent (35%) of the Holsteins received a QG of Choice or above while 74% of crossbreds graded USDA Choice or above (P = 0.01). However, 75% of Holsteins were YG 2 or lower while only 45% of crossbreds achieved YG 2 or less (P = 0.05). There was no improvement in efficiency when crossbreds were compared to Holsteins; however, carcasses from crossbreds were more likely to grade USDA Choice or above while yielding greater REA and backfat than Holsteins.

331 Effects of Dried Distillers’ Grains Cube Supplementation Rate on Voluntary Intake and Digestibility of Bermudagrass Hay Fed to Growing Heifers

The objective of this study was to evaluate supplementation rates of dried distillers’ grains cubes (DDGS) on voluntary intake (DMI), rate and extent of digestibility, and blood parameters of growing Charolais-cross heifers (BW = 286 ± 28.9 kg) fed ad libitum bermudagrass (Cynodon dactylon) hay. For the 29-d study, heifers were randomly assigned to one of four supplementation treatments: 1) Control, no supplement (n = 6); 2) Low, supplemented 0.90 kg/d (n = 6); 3) Intermediate, supplemented 1.81 kg/d (n = 5); or 4) High, supplemented 3.62 kg/d (n = 6). Heifers were offered supplement each morning in individual stalls. From d 15 to 25, heifers were dosed twice daily with titanium dioxide in gelatin capsules (10 g/d), and fecal samples were collected via rectum at time of dosing from d 22 to 25 to estimate fecal output. Post-dosing, fecal sampling continued over 96-h from d 25 to 29 to determine passage rate (Kp) via titanium dioxide analysis. Blood was collected from each animal on d 26 via jugular venipuncture before supplementation, and 4 and 8-h post-supplementation for analysis of blood urea N (BUN), lactate, and glucose. Samples of feces, hay, and supplement were incubated in rumen-cannulated Holstein steers (n = 4; BW = 281 ± 29.5 kg) for 576-h to estimate digestibility with indigestible neutral detergent fiber as an internal marker. Data were analyzed by ANOVA using the mixed procedure of SAS (SAS Inst. Inc. Cary NC), with treatment least-squares means separated using orthogonal polynomial contrasts. Increasing DDGS linearly (P < 0.01) decreased forage DMI linearly, but linearly increased Kp, total diet DMI, and total diet digestibility. Linear increases (P ≤ 0.02) in glucose, lactate, and BUN were likewise observed with increasing DDGS. Increasing DDGS supplementation to growing calves consuming bermudagrass hay may increase productivity while reducing forage intake.

PSIII-19 Soil nutrient profile from cool-season forages fertilized with manure from steers supplemented with titrated levels of dried distillers grains

Dried distillers grains with solubles (DDGS) is commonly used as supplemental feed in cattle rations. However, the systemic effects of overfeeding DDGS, especially to potential fertilizer benefits of pass-through nitrogen, are widely unknown. Therefore, our objective was to evaluate plant and soil response to fertilization with manure from steers supplemented with titrated levels of DDGS. Manure utilized was collected from steers supplemented with DDGS (0%, 0.25%, 0.5%, and 1% BW) during a 2-yr experiment. The experimental design was a randomized complete block design with an augmented factorial treatment structure wherein benches represented blocks. The factorial was made up of manure treatment (0, 0.25, 0.5, or 1% BW DDGS, chemical fertilizer, or none) soil type (Windthorst or Purves), and plant species (none, crimson clover, or rye). Pots were sown (5 seeds/pot) and grown in a greenhouse for 35 d. Water was applied daily at 90% evapotranspiration. After harvest, soils were sifted, dried for 72 h at 55°C, then assayed for C, N, NO3-N, P, K, Ca, Mg, Na, and S. There was an interaction of manure and soil type for soil C (P < 0.01). Purves soils amended with any manure had a greater (P < 0.05) concentration of C (1.8%) than did the negative control (1.3%). From Windthorst, soil C was greatest from 1% BW DDGS manure (1.9%), and least from 0% DDGS manure (1.5%), with 0.25 and 0.5% manures and the negative control intermediate. There was an interaction of manure, soil type, and forage for soil N (P < 0.01). Manures with higher levels of supplementation had greater (P < 0.05) soil N than lower levels of supplementation or the negative control. Legumes had greater soil N than grasses. Results are interpreted to mean that moderate supplementation of steers with DDGS may yield soil nutrient benefits through nutrient deposition.

335 Evaluation of Hempseed Cake on Cattle Performance, Carcass Characteristics and Feeding Behavior in Finishing Diets

As cannabinoid production continues to increase, there is increasing interest in feeding byproducts of industrial hemp production to livestock. An experiment using crossbred heifers (n = 31; initial BW= 494 kg, SE = 10) was conducted to determine the effects of feeding hempseed cake in a corn-based finishing diet (10% forage) formulated to meet or exceed ruminally degradable and metabolizable protein requirements on growth, performance, carcass characteristics, and feeding behavior. Heifers were assigned randomly to one of two treatments: 1.) diet containing 20% dried distillers grains plus solubles (CON, n = 16), or 2.) diet containing 20% hempseed cake (HEMP, n = 15) on a dry-matter basis. Cattle were housed in two pens, had ad-libitum access to feed and water, and individual intakes and feeding behavior were captured using the Insentec BV feeding system across the feeding period (111 d). Final BW was not different (P = 0.28) between CON (696 kg, SE = 12) and HEMP (683 kg, SE = 12) heifers. Dry matter intake was not different between treatments (P = 0.99), while CON cattle had improved ADG and feed efficiency (G:F; P ≤ 0.04) compared to HEMP cattle. Carcass characteristics were not different (P ≥ 0.20) between treatments for all parameters measured. Control and HEMP cattle were not different (P ≥ 0.34) for number of meals, time spent eating, number of visits to the bunk per day, meal size, or eating rate. Feeding hempseed cake reduced ADG and G:F while having no effect on other performance measures, carcass characteristics, or feeding behavior. Overall, these data suggest hempseed cake could be a viable alternative feed source for ruminants depending on availability and cost. Further understanding of hempseed cakes’ nutrient utilization is critical to determining this products viability as a feedstuff for cattle.

PSXIII-6 Effects of cyclic monensin feeding on ruminally cannulated beef steers consuming low-quality forage

The loss of monensin efficacy when fed continuously requires further study for development of novel feeding strategies that may prolong its effectiveness. In the present study, effects of cyclic monensin feeding on utilization of low-quality forage (LQF; 4.9%CP) were evaluated using ruminally cannulated steers (12 Bos taurus; 260 kg BW). Steers were randomly assigned to one of three treatments: 1) CON (0 mg∙hd-1∙d-1 monensin; Rumensin® 90, Elanco Animal Health, Greenfield, IN), 2) MON (200 mg∙hd-1∙d-1 monensin) or 3) CYC (200 mg∙hd-1∙d-1 monensin for 14 d and 0 mg∙hd-1∙d-1 monensin for subsequent 14 d). Dried distillers grains (1 kg∙hd-1∙d-1) were fed for monensin inclusion. Each of four periods were 28 days in length. Hay, ort, and fecal samples were collected d 10–14 of each period for measures of digestion. Rumen fluid was collected with a suction strainer 0, 2, 4, 8, and 12 h after feeding on d 14 for VFA analysis. Data were analyzed using the MIXED procedure of SAS 9.4 (SAS Inst. Inc., Cary, NC). A period × treatment interaction was not observed for any measure of digestion (DMD, OMD, NDFD; P ≥ 0.39). A period × treatment interaction (P < 0.01) was observed for acetate, propionate, and A:P. An hour effect was observed for all ruminal fermentation parameters (acetate, propionate, A:P ratio, total VFA; P ≤ 0.01). No treatment effects or interactions were observed for any ruminal fermentation parameters by period 4 (P ≥ 0.15), but an hour effect was observed for all parameters (P ≤ 0.03) in period 4. Exploration of novel feeding strategies results in knowledge beef cattle producers can apply in their operations. This data is particularly relevant in cow-calf operations where LQF is often consumed. Although cyclically feeding monensin was similar to continuous feeding, this research furthers our knowledge and understanding of monensin.

Occurrence and concentration of mycotoxins in maize dried distillers’ grains produced in Brazil

The presence of mycotoxins in dried distillers’ grains with solubles (DDGS), a by-product of bioethanol production from maize, has been a matter of concern due to the increasing global utilisation of this ingredient in animal feed. In this study, 186 samples of maize DDGS produced in Brazil were analysed for the presence of major mycotoxins: aflatoxins (B1, B2, G1, and G2), fumonisins (B1 and B2), zearalenone (ZEN), deoxynivalenol (DON) and ochratoxin A (OTA). Samples were provided by the local industry between January 2017 and October 2020, and mycotoxins were quantified by LC-MS/MS. More than 98% of the analysed samples were contaminated with mycotoxins, from which 59.9% had a single mycotoxin, 29.9% two mycotoxins, and 9.1% more than two mycotoxins. The most prevalent metabolites were fumonisin B1 and B2, being detected in 98.8% (mean 3,207 μg/kg) and 97.6% (mean 1,243 μg/kg) of the samples, respectively; aflatoxin B1 had the third highest positivity, with 32.3% (mean 1.47 μg/kg), followed by ZEN, with 18.01% (mean 18.2 μg/kg), DON, with 12.9% (mean 59.6 μg/kg), and OTA was not detected. Co-occurrence of total aflatoxins (AFT = aflatoxin B1+B2+G1+G2) and total fumonisins (FBT = fumonisin B1+B2) was observed in 32.07% of the samples analysed for these mycotoxins. Co-occurrence of AFT and ZEN was found in 7.84% of the samples analysed for such mycotoxins, while FBT and DON co-occurred at 13.01%. AFT, FBT, DON and ZEN co-occurred in only one sample (0.84%). Except for FBT, a considerable number of samples presented the evaluated mycotoxins below their respective limit of quantification (LOQ) with percentages of 67.61% for AFT, 81.99% for ZEN, 87.07% for DON and 100% for OTA. Since the production of bioethanol and its by-products is growing worldwide, including in Brazil, mycotoxicological monitoring of maize DDGS is crucial to identify the effects of mycotoxins occurrence in animal feed formulated with this ingredient.