STORAGE STABILITY OF COMMERCIAL MILK1

1968 ◽  
Vol 31 (12) ◽  
pp. 382-387 ◽  
Author(s):  
R. D. Finley ◽  
H. B. Warren ◽  
R. E. Hargrove
Keyword(s):  
Shelf Life ◽  
Storage Temperature ◽  
Plate Count ◽  
Lag Phase ◽  
Decay Period ◽  
Total Plate Count ◽  
Product Acceptability ◽  
Iodine 131 ◽  
Storage Temperatures ◽  
Temperature Storage

Storage of fluid milk for extended times at low temperature appears feasible. The extended shelf life is long enough to allow a 100-fold decay of Iodine-131 under emergency conditions. This theoretical decay period may be 4 to 8 weeks depending on degree of contamination and extent of depositions on pasturage. Commercially produced summer milk stored at 32 F, averaged 4.4 weeks or 5 times its life at 45 F. Summer milks possessed twice the shelf life of winter milks. Shelf life was materially affected by pasteurization temperature, storage temperature, and season as determined by taste panel and bacteriological tests. Marked increases in shelf life were observed with reduced storage temperatures. Criteria for product acceptability were flavor score (35.0 or higher), total plate count, and psychrophilic plate count (less than 1 million per ml). UHT processing at 200 to 220 F for 0.5 to 16 sec yielded as much as 20 weeks acceptable shelf life at 32 F. A combination of UHT pasteurization, 32 F storage to the end of microbial lag phase, and repasteurization followed by refrigerated holding extended storage life to as much as 23 weeks, depending on storage temperature.

scholarly journals Microbiological, chemical, and sensory assessment of Pacific oysters (Crassostrea gigas) stored at different temperatures

2009 ◽  
Vol 27 (No. 2) ◽  
pp. 102-108 ◽  
Author(s):  
R. Cao ◽  
Ch.-H. Xue ◽  
Q. Liu ◽  
Y. Xue
Keyword(s):  
Shelf Life ◽  
Storage Temperature ◽  
Plate Count ◽  
Lag Phase ◽  
Sensory Assessment ◽  
Pacific Oysters ◽  
Basic Nitrogen ◽  
Different Temperatures ◽  
Aerobic Plate Count ◽  
Dominant Bacteria

The changes were studied in microbiological, chemical, and sensory properties of Pacific oysters stored at 10°C, 5°C, and 0°C. <I>Pseudomonas</I> (22%) and <I>Vibrionaceae</I> (20%) species were dominant in raw oysters. The dominant bacteria found in the spoiled samples were <I>Pseudomonas</I> regardless of the storage temperature. During storage, rapid increases in aerobic plate count (APC) values of the samples stored at 10°C and 5°C were observed, while no obvious lag phases were detected. With the samples stored at 0°C, a decrease in APC value during the first 4 days and a lag phase of about 6 days were observed. The APC values of the samples stored at 10°C, 5°C, and 0°C reached the level of 10<sup>7</sup> CFU/g on day 6, 10, and 18, respectively. All the tested samples stored at different temperatures revealed a slight decrease in pH and a significant increase of total volatile basic nitrogen (TVB-N) during storage. The average TVB-N concentration of about 22.0 mg N/100 g was observed at the end of the shelf-life as determined by APC. Combined with the sensory assessments, the shelf-life of 6–7, 10–11, and 17–18 days for oysters stored at 10°C, 5°C, and 0°C, respectively, was determined.

Effect of cooking oil on the characteristics and shelf life of shredded catfish (Clarias sp)

2021 ◽  
Vol 924 (1) ◽  
pp. 012090
Author(s):  
S Suryanti ◽  
T D Suryaningrun ◽  
D Ikasari
Keyword(s):  
Moisture Content ◽  
Shelf Life ◽  
Peroxide Value ◽  
Salt Solution ◽  
Plate Count ◽  
Cooking Oil ◽  
Total Plate Count ◽  
Cooking Process ◽  
Acceleration Method ◽  
Storage Temperatures

Abstract The purpose of this research is to identify the characteristics of shredded catfish (Clarias sp) processed with and without cooking oil and determine the shelf life by using the Arrhenius method. The shredded catfish was made by filleting the fish and soaking in a 2% vinegar solution for 10 minutes, and boiling the fillets for 15 minutes in a 2% salt solution mixed with 2% bay leaves and 2% lemongrass with the ratio of fillet: solution (1:2 (w/v)). The cooked fillets were then pressed, shredded into small pieces, and added with spices (2% red onion, 3% garlic, 15% granulated sugar, 1% coriander, 1% galangal, and 0.5% flavoring powder) and 20% coconut milk, then cooked until it dried. The shredded catfish was observed for its proximate values, while the shelf life was determined using the acceleration method (Arrhenius) at three different storage temperatures and day of observation, i.e. at 25°C was for 0, 10, 20, 30, 40 days; at 35°C was for 0, 7, 14, 21, 28 days and at 45°C was for 0, 3, 6, 9, 12 days. The parameters of observation for shredded catfish’s shelf life were peroxide value, Aw, total plate count (TPC), and sensory test (hedonic). The result of proximate value showed that the protein content of shredded catfish with oil was lower than without oil, while moisture content was higher for treatment using oil. The shelf life of shredded catfish with cooking oil was shorter than without cooking oil, estimated for 83 days at 25°C, 55 days at 35°C, 47 days at 45°C, compared to 155 days at 25°C, 103 days at 35°C, and 62 days at 45°C, respectively. This was supported by the panelist’s preferences for shredded catfish without oil at the end of the observation. These results indicate that the use of cooking oil during the cooking process of shredded catfish greatly affects the product’s shelf life.

Pengaruh Suhu Penyimpanan terhadap Organoleptik, Derajat Keasaman dan Pertumbuhan Bakteri Coliform pada Susu Pasteurisasi

2016 ◽  
Vol 10 (1) ◽  
pp. 13-23 ◽  
Author(s):  
Agustina Arianita Cahyaningtyas ◽  
Wiwik Pudjiastuti ◽  
Ilham Ramdhan
Keyword(s):  
Storage Temperature ◽  
Total Coliform ◽  
Coliform Bacteria ◽  
Plate Count ◽  
Pasteurized Milk ◽  
Initial Analysis ◽  
Total Plate Count ◽  
Plate Count Method ◽  
Pathogenic Microbes ◽  
Total Coliform Bacteria

One attempt to reduce the number of pathogenic microbes in milk is through the pasteurization process. This research aims to determine the effect of storage temperature on the organoleptic, acidity (pH) and growth of coliform bacteria in pasteurized milk. Pasteurized milk is stored at the varies of temperature  4°C (observed for 14 days), 10°C-15°C (observed for 14 days) and 25°C-27°C (observed for 22 hours), as well as also conducted an initial analysis pasteurized milk. The parameters were observed among other organoleptic (smell, taste, color, texture), pH and total coliform bacteria. Testing acidity using pH paper, while the growth of coliform bacteria testing done using Total Plate Count method based on ISO 2897 in 2008. The results of this study indicate that storage at 4°C for 14 days, organoleptic pasteurized milk is still good until the day ke- 8, pH progressively decreases, and the growth of coliform bacteria obtained the highest score of 3100x101 CFU / ml. Storage at 10°C-15°C for 14 days, organoleptic pasteurized milk is still good until the 6th day, the pH progressively decreases, and the growth of coliform bacteria obtained the highest score of 5729x101 CFU / ml. Storage at 25°C-27°C for 22 days, organoleptic pasteurized milk is still good until the 9th, pH progressively decreases, and the growth of coliform bacteria obtained the highest score of 4.3 x106 CFU / ml.ABSTRAKSalah satu usaha untuk mengurangi jumlah mikroba patogen pada susu adalah melalui proses pasteurisasi. Penelitian ini bertujuan untuk mengetahui pengaruh suhu penyimpanan terhadap organoleptik, derajat keasaman (pH) dan pertumbuhan bakteri Coliform pada susu pasteurisasi. Susu pasteurisasi disimpan pada suhu yang bervariasi yaitu suhu 4°C (diamati selama 14 hari), suhu 10°C-15°C (diamati selama 14 hari) dan suhu 25°C-27°C (diamati selama 22 jam), serta dilakukan pula analisa awal susu pasteurisasi. Parameter yang diamati antara lain organoleptik (bau, rasa, warna, tekstur), pH dan jumlah bakteri Coliform. Pengujian derajat keasaman menggunakan kertas pH, sedangkan pengujian pertumbuhan bakteri Coliform dilakukan dengan menggunakan metode Total Plate Count berdasarkan SNI 2897 Tahun 2008. Hasil penelitian ini menunjukkan bahwa penyimpanan pada suhu 4°C selama 14 hari, organoleptik susu pasteurisasi masih baik sampai dengan hari ke-8, pH semakin lama semakin menurun, dan pertumbuhan bakteri Coliform didapatkan nilai tertinggi sebesar 3100x101 Cfu/ml. Penyimpanan pada suhu 10°C-15°C selama 14 hari, organoleptik susu pasteurisasi masih baik sampai hari ke-6, pH semakin lama semakin menurun, dan pertumbuhan bakteri Coliform didapatkan nilai tertinggi sebesar 5729x101 Cfu/ml. Penyimpanan pada suhu 25°C-27°C selama 22 hari, organoleptik susu pasteurisasi masih baik sampai jam ke-9, pH semakin lama semakin menurun, dan pertumbuhan bakteri Coliform didapatkan nilai tertinggi sebesar 4,3 x106 Cfu/ml.Kata kunci : bakteri coliform, derajat keasaman, suhu penyimpanan, organoleptik, susu pasteurisasi

scholarly journals Effect of Humidity-Controlled Dehydration on Microbial Growth and Quality Characteristics of Fresh Wet Noodles

Foods ◽  
2021 ◽  
Vol 10 (4) ◽  
pp. 844
Author(s):  
Jun-Jie Xing ◽  
Dong-Hui Jiang ◽  
Zhen Yang ◽  
Xiao-Na Guo ◽  
Ke-Xue Zhu
Keyword(s):  
Shelf Life ◽  
Microbial Growth ◽  
Treatment Time ◽  
Positive Influence ◽  
Quality Characteristics ◽  
Plate Count ◽  
Cooking Properties ◽  
Total Plate Count ◽  
Different Temperatures

Humidity-controlled dehydration (HCD) was innovatively applied in this paper to control the growth of microorganisms in fresh wet noodles (FWN). Effects of HCD treatment with different temperatures (40, 60 or 80 °C), relative humidity (RH, 50%, 70% or 90%) and treatment time (5–32 min) on the total plate count (TPC), the shelf-life, and qualities of FWN were investigated. The results showed that HCD reduced the initial microbial load on the fresh noodles and extended the shelf-life up to 14–15 days under refrigeration temperature (10 °C). A 1.39 log10 CFU/g reduction for the initial TPC was achieved after HCD treatment at the temperature of 60 °C and RH of 90%. HCD with higher RH had a more positive influence on quality improvement. The L* values, the apparent stickiness, and the cooking properties of the noodle body were improved by HCD while good sensory and texture quality of noodles were still maintained after the dehydration process.

scholarly journals Shelf Life Studies of Three Wasabi Flavoured Sauces

1970 ◽  
Vol 44 (2) ◽  
pp. 147-156
Author(s):  
Tamanna Sultana ◽  
GP Savage ◽  
NG Porter ◽  
DL McNeil ◽  
JR Sedcole
Keyword(s):  
Shelf Life ◽  
Storage Temperature ◽  
Initial Level ◽  
Tomato Sauce ◽  
Wasabia Japonica ◽  
Different Temperatures ◽  
Small Change ◽  
Shelf Life Studies ◽  
The Stability ◽  
Storage Temperatures

Isothiocyanates (ITCs) contained in purees extracted from wasabi (Wasabia japonica (Miq) Matsum) can be used to manufacture a range of interesting spicy foods. In New Zealand, local manufacturers are showing interest in producing various forms of processed wasabi based sauces. However, isothiocyanates have been shown to degrade quickly in some situations. Therefore, in this study, the stability of allyl ITC was investigated in three wasabi flavoured products stored at four different temperatures (4, 10, 20 and 30°C) for 22 weeks. Two creamy (mayonnaise and tartare) sauces and a non-creamy sauce were prepared from an original recipe and flavoured with a known volume of "wasabi oil". Two types of pouches (clear and metallic plastic) were used to store each product and allyl ITC content was measured in the stored sauces at two week intervals. The initial level of allyl ITC found in mayonnaise, tartare and smoky tomato sauces were 415.3, 411.4 and 144.7 mg/ kg respectively, prior to storage. Temperature showed a strong influence in reducing allyl ITC (P=0.005 to <0.001) but no significant effect was identified for the two types of packets used. The non-creamy smoky tomato sauce was very unstable at 10°C or higher temperatures and the allyl ITC contents reduced rapidly with increasing storage temperatures. For instance, at 30°C, a 66% loss occurred by week 2 and a 90% loss occurred by week 6 in the smoky tomato sauce. However, mayonnaise and tartare sauces had a shelf life of 8 to 9 weeks with only a marginal reduction in allyl ITC (2% overall) at all the stored temperatures (4-30°C). These creamy sauces were characterized by a sudden fall in 10 weeks ending in a 69-70% loss of allyl ITC at 22 weeks. No microbial growth occurred in any of the sauces stored at any of the temperatures during the course of this storage experiment though very small change of colour was noticed for the sauces when stored at 30°C. Keywords: Bangladesh J. Sci. Ind. Res. 44(2), 147-156, 2009DOI: 10.3329/bjsir.v44i2.3665Bangladesh J. Sci. Ind. Res. 44(2), 147-156, 2009

Note. Effect of Storage Temperature on the Shelf Life of Hass Avocado (Persea Americana)

2004 ◽  
Vol 10 (2) ◽  
pp. 73-77 ◽  
Author(s):  
K. Perez ◽  
J. Mercado ◽  
H. Soto-Valdez
Keyword(s):  
Weight Loss ◽  
Shelf Life ◽  
Respiration Rate ◽  
Ethylene Production ◽  
Storage Temperature ◽  
Persea Americana ◽  
Co2 Production ◽  
Hass Avocado ◽  
Storage Temperatures

The effect of storage temperature on the shelf life, weight loss, respiration rate and ethylene production of Hass avocado (Persea americana Mill) was studied. Two batches of green mature avocado fruits, classified as ‘‘super extra’’ were stored at 10 and 20 C (first batch) and at 7 and 25 C (second batch). The avocado shelf lives were 22, 8, 32 and 6 days at 10, 20, 7 and 25 C, respectively. Based on the data of the first assay Q10 was calculated as 2.75, with this value the predicted shelf life at 7 and 25 C were 29.8 and 4.8 days, respectively. That meant shelf life was underestimated 7 and 20% at 7 and 25 C, respectively. Weight loss was linear at both the storage temperatures, it was 4.3% in fruits at 20 C for 8 days and 3.0% at 10 C for 22 days. The maximum CO2 production at 20 C was reached during the second day of storage, while at 10 C it was reached at the 17th day (176.17 15.98 and 74.73 7.32 mL/kg h, respectively). The maximum ethylene production at 20 C was reached the second day of storage, and at 10 C the 6th day (239.06 54.55 and 28.00 8.12 mL/kg h, respectively).

scholarly journals UMUR SIMPAN SAMBAL PARI (Dasyatis Sp.) ASAP YANG DIKEMAS JAR PADA BEBERAPA CARA PEMASAKAN DENGAN METODE PENDUGAAN ACCELERATED SHELF-LIFE TESTING (ASLT)

2020 ◽  
Vol 13 (2) ◽  
pp. 118
Author(s):  
Dian Rachmawanti Affandi ◽  
Adhitya Pitara Sanjaya ◽  
Santi Rahma Mardiana
Keyword(s):  
Shelf Life ◽  
Plate Count ◽  
Life Testing ◽  
Total Plate Count

<p>Penambahan ikan pari asap pada pembuatan sambal dapat menjadi alternatif pengolahan ikan pari asap dan menghasilkan sambal dengan cita rasa khas. Selama penyimpanan, sambal mengalami penurunan mutu secara mikrobiologi serta menyebabkan perubahan aroma dan timbulnya asam pada sambal sehingga produk ditolak oleh konsumen. Penelitian ini bertujuan untuk mengetahui pengaruh variasi cara kualitas sensoris, kimiawi, dan mikrobiologis sambal ikan pari asap kemasan <em>jar </em>kaca selama penyimpanan, umur simpan sambal, serta menentukan cara pemasakan untuk memperpanjang umur simpan sambal. Pengemasan menggunakan <em>jar </em>kaca dan variasi cara pemasakan pada sambal ikan pari asap dilakukan untuk mencegah penurunan mutu. Variasi cara pemasakan yang dilakukan yaitu pemasakan kering (P1), pemasakan setengah kering (P2), dan pemasakan kering dengan penambahan minyak setelah pemasakan (P3). Selanjutnya, untuk memenuhi standar keamanan pangan dan sebagai jaminan mutu dilakukan pendugaan umur simpan sambal ikan pari asap menggunakan metode ASLT model Arrhenius yang memiliki waktu pengujian relatif singkat dengan ketepatan dan akurasi tinggi.  Parameter yang diuji adalah sensoris aroma, total asam tertitrasi (TAT), dan <em>total plate count </em>(TPC). Penurunan mutu sambal diamati pada penyimpanan suhu 35˚C, 45˚C dan 55˚C selama 48 jam dengan waktu pengamatan setiap 12 jam sekali. Berdasarkan hasil peneli tian, tiga variasi cara pemasakan sambal ikan pari asap memiliki penurunan mutu yang berbeda-beda selama penyimpanan. Umur simpan sambal ikan pari asap kemasan <em>jar</em> kaca menurut parameter kritis TAT pada cara pemasakan kering (P1) pada suhu 30˚C adalah 165,95 jam. Pada variasi pemasakan setengah kering (P2), umur simpan sambal pada suhu 30˚C adalah 155,04 jam. Pada variasi pemasakan kering dengan penambahan minyak (P3), umur simpan sambal pada suhu 30˚C adalah 197,96 jam. Variasi pemasakan kering dengan penambahan minyak goreng setelah pemasakan merupakan cara terbaik untuk memperpanjang umur simpan sambal ikan pari asap kemasan <em>jar </em>kaca.</p><p> </p><br clear="ALL" /><p> </p>

scholarly journals KEBERADAAN MIKROBA PADA BAKSO IKAN ASAP CAIR, YANG DIKEMAS DALAM RETORTABLE POUCH, DIPASTEURISASI DAN DISIMPAN PADA TEMPERATUR RUANG

2016 ◽  
Vol 4 (2) ◽  
pp. 85
Author(s):  
Margani Luyuani Rohana ◽  
Siegfried Berhimpon ◽  
Joyce CV Palenewen
Keyword(s):  
Shelf Life ◽  
Water Content ◽  
Experimental Method ◽  
Room Temperature ◽  
Plate Count ◽  
E Coli ◽  
Existing Problems ◽  
Liquid Smoke ◽  
Total Plate Count ◽  
And Storage

A research has been done to assess the presence of microbes and the shelf life of fish balls dipped in liquid smoke, packed in retortable pouch, pasteurized, and stored at room temperature. The method used in this research is an experimental method that revealed the facts based on existing problems through hypothesis testing. Parameters assessed are Total Plate Count (TPC), total Salmonella, total coliforms and E. coli, total vibrio, water content, and pH. Fish balls were pasteurized in 85ºC and stored in room temperature for 0, 3, 6, and 9 days, and were pasteurized at 100°C and storage in room temperature for 0, 9, 18, and 27 days. The results shown that all pathogen were negative, but based on Indonesian standard (SNI 01-7266-1-2006) especially TPC value, fish balls were packaged in retortable pouch and without pasteurized is no longer acceptable for consumption after 3 days of storage, and fish balls were packaged in retortable pouch and pasteurized at 85ºC no longer acceptable for consumed after 6 days of storage. While the fish balls are packaged in retortable pouch and pasteurized at 100°C is no longer acceptable for consumed after 18 days of storage.Keyword: Retortable Pouch, Pasteurization, Pathogens.  Penelitian ini bertujuan untuk mengetahui keberadaan mikroba dan daya awet bakso ikan yang direndam dalam asap cair dan dikemas dalam Retortable pouch, dipasteurisasi, dan disimpan pada temperatur ruang. Metode yang digunakan dalam penelitian ini adalah metode eksperimen untuk menguji hipotesa. Parameter yang diamati yaitu Angka Lempeng Total (ALT), Salmonella, total koliform dan E.coli, total vibrio, analisa kadar air, dan nilai pH. Bakso ikan asap cair yang dipasteurisasi pada 85ºC, disimpan pada temperatur ruang selama 0, 3, 6, dan 9 hari, dan yang dipasteurisasi pada 100ºC, disimpan pada temperatur ruang selama 0,9,18, dan 27 hari. Hasil penelitian menunjukkan bahwa bakso ikan yang dikemas dalam Retortable pouch, tanpa dipasteurisasi sudah tidak layak lagi untuk dikonsumsi setelah penyimpanan 3 hari, dan bakso ikan yang dikemas dalam Retortable pouch dan dipasteurisasi pada 85ºC sudah tidak layak lagi untuk dikonsumsi setelah penyimpanan 6 hari. Bakso ikan yang dikemas dalam Retortable pouch, dan dipasteurisasi pada 100ºC nanti tidak layak lagi dikonsumsi setelah penyimpanan 18 hari.Kata Kunci: Kemasan Retortable Pouch, Pasteurisasi, Patogen.

scholarly journals Food Handlers Personal Hygiene in The Cafeteria of SDN Model and its impacts on Total Plate Count (TPC) in Food

2019 ◽  
Vol 11 (3) ◽  
pp. 252
Author(s):  
Upi - Almasari ◽  
Corie Indria Prasasti
Keyword(s):  
Storage Temperature ◽  
Food Samples ◽  
Personal Hygiene ◽  
Plate Count ◽  
Food Handler ◽  
Food Handlers ◽  
Microbiological Contamination ◽  
Storage Duration ◽  
Cross Sectional ◽  
Total Plate Count

Canteen has an important role to provide of nutritious and safe food for students during school hours with relatively affordable prices. The results of Food and Drugs Monitoring (BPOM) inspection in 2013 by taking a sample of School Children Confectionary (PJAS) found that 80.79% of the samples confirmed as free from microbiological contamination. These results decrease in 2014, whereas PJAS samples confirmed as free from microbiological contamination is was 76.18%. This study aimed to analyze the implementation of personal hygiene food handlers in the cafeteria of SDN Model to figures Total Plate Count (TPC) in food. This was a descriptive study using cross sectional design. Samples were taken with total sampling where the sample size in this study was the total population of cafeteria booth at SDN Model, there are 5 booths canteen, 5 food handlers, and 5 food samples were taken from each canteen booth. All food samples were tested for bacteriological quality using Total Plate Count (TPC) parameter. The use of Personal Protective Equipment (PPE) such as mask, gloves, headgear, and apron is important to minimize contamination of microorganism from food handlers to food produced. In addition, the selection of ingredients, storage duration, and storage temperature are required to be considered. Suggestion for the cafeteria supervisor of SDN Model and food handler: for the cafeteria supervisor SDN Model to impose regulation and education for food handlers to use PPE during food processing. It is suggested to food handlers to get used to in using PPE during processing the food

scholarly journals Verification of prediction of growth of Listeria monocytogenes micro-organism in chicken meat

2000 ◽  
Vol 18 (No. 5) ◽  
pp. 183-186
Author(s):  
A. Landfeld ◽  
M. Karpíšková R Houška ◽  
K. Kýhos ◽  
P. Novotná
Keyword(s):  
Listeria Monocytogenes ◽  
Incubation Temperature ◽  
Chicken Meat ◽  
Raw Material ◽  
Plate Count ◽  
Raw Meat ◽  
Total Plate Count ◽  
Measured Water ◽  
Number Of Bacteria ◽  
Storage Temperatures

Raw chicken meat was comminuted and homogenised. There were measured water activity and pH (aw = 1 for temperature 25°C, pH = 5.8 for temperature 8°C). Input raw material was investigated for the presence of Listeria monocytogenes (negative) and the raw meat was inoculated by Listeria monocytogenes CCM 4699. Number of Listeria monocytogenes, total plate count and number of coliforms were determined in the range 0–7 days by bacteriological survey for the storage temperatures 4.9, 7 and 8.3°C. The increase of Listeria monocytogenes counts has been registered for temperature 4.9°C about log 1.5 CFU/g after 6 days, for temperatures 7 and 8.3°C about 2 log CFU/g (regarding to the starting counts). The prediction for listeria growth with the aid of Food MicroModel was also made. The best agreement between the experimentally analysed number of bacteria and prediction was received for the lowest incubation temperature 4.9°C.

Sign in / Sign up

Export Citation Format

Share Document